The control techniques for indirect heating digestion in Bayer process of alumina production were researched and developed. They include controlling chemical composition of slurry to be digested and controlling diges...The control techniques for indirect heating digestion in Bayer process of alumina production were researched and developed. They include controlling chemical composition of slurry to be digested and controlling digestion status and energy consumption. Very good performances and technical and technical and economical figures for digestion process have been obtained by carefully applying these comprehensive control techniques in Pingguo alumina refinery.展开更多
Thermodynamic diagrams of Na−S−Fe−H_(2)O system were constructed to analyze the behavior of sulfur and iron in the Bayer process.After digestion,iron mainly exists as Fe_(3)O_(4) and Fe_(2)O_(3) in red mud,and partial...Thermodynamic diagrams of Na−S−Fe−H_(2)O system were constructed to analyze the behavior of sulfur and iron in the Bayer process.After digestion,iron mainly exists as Fe_(3)O_(4) and Fe_(2)O_(3) in red mud,and partial iron transfers into solution as Fe(OH)_(3)^(−),HFeO_(2)^(−),Fe(OH)_(4)^(−)and Fe(OH)_(4)^(2−).The dominant species of sulfur is S^(2−),followed by SO_(4)^(2−),and then SO_(3)^(2−)and S_(2)O_(3)^(2−).The thermodynamic analysis is consistent with the iron and sulfur species distribution in the solution obtained by experiments.When the temperature decreases,sulfur and iron can combine and precipitate.Controlling low potential and reducing temperature are beneficial to removing them from the solution.XRD patterns show that NaFeS_(2)·2H_(2)O,FeS and FeS_(2) widely appear in red mud and precipitates of pyrite and high-sulfur bauxite digestion solution.Thermodynamic analysis can be utilized to guide the simultaneous removal of sulfur and iron in the Bayer process.展开更多
A quantitative Fourier transform infrared (FTIR) technique mas established by comparison with chemical analysis and quantitative X-ray diffraction (XRD) analysis. By the quantitative FTIR analysis of bauxite during di...A quantitative Fourier transform infrared (FTIR) technique mas established by comparison with chemical analysis and quantitative X-ray diffraction (XRD) analysis. By the quantitative FTIR analysis of bauxite during dissolution , the process of dissolution and precipitation of silica was found to occur in three stages. In the first stage, there was no precipitation of desilication product (DSP). All the silica dissolved from kaolinite went into the solution. In the second stage, the silica concentration in solution attained a maximum and then dropped very quickly. The precipitation of DSP was the main cause of the reduction of the silica concentration in solution. In the third stage, the concentration of DSP reached a constant level. The dissolution and precipitation process gradually attained an equilibrium. The mechanism of silica dissolution and DSP precipitation was discussed on the basis of the FTIR quantitative analysis of kaolinite and DSP in bauxite.展开更多
Digesting aluminum-bearing minerals and converting ferric oxide to magnetite simultaneously in Bayer digestion process is crucially important to deal with high-iron diasporic bauxite economically for alumina productio...Digesting aluminum-bearing minerals and converting ferric oxide to magnetite simultaneously in Bayer digestion process is crucially important to deal with high-iron diasporic bauxite economically for alumina production.The reaction behaviors of hydrothermal reduction of ferric oxide in alkali solution were studied by both thermodynamic calculation and experimental investigation.The thermodynamic calculation indicates that Fe3O4 can be formed by the conversion of Fe2O3 at proper redox potentials in alkaline solution.The experimental results show that the formation ratio of Fe3O4 either through the reaction of Fe and Fe2O3 or through the reaction of Fe and H2O in alkaline aqueous solution increases remarkably with raising the temperature and alkali concentration,suggesting that Fe（OH）3- and Fe（OH）4- form by dissolving Fe and Fe2O3,respectively,in alkaline aqueous solution and further react to form Fe3O4.Moreover,aluminate ions have little influence on the hydrothermal reduction of Fe2O3 in alkaline aqueous solution,and converting iron minerals to magnetite can be realized in the Bayer digestion process of diasporic bauxite.展开更多
The conversion mechanism of Al-goethite under the action of different additives(lime or reductant for typical or reductive Bayer digestion)was investigated by thermodynamic calculation,XRD,and SEM-EDS.The results show...The conversion mechanism of Al-goethite under the action of different additives(lime or reductant for typical or reductive Bayer digestion)was investigated by thermodynamic calculation,XRD,and SEM-EDS.The results show that the formation of Fe-substituted hydrocalumite is crucial to converting Al-goethite to hematite during Bayer digestion by adding lime.However,the conversion proceeds more easily under the action of reductant due to the rapid formation of magnetite.Additionally,Bayer liquor composition significantly affects the product composition and also the conversion rate of Al-goethite.Compared to typical Bayer digestion with Al-goethite containing gibbsitic bauxite as raw material,the red mud yield of reductive Bayer digestion decreases from 39.02%to 31.19%,and the grade of TFe in red mud increases from 41.66%to 53.80%.展开更多
By means of Malvern laser particle size analyzer and scanning electron microscopy, the influences of seed size and number on agglomeration in Bayer process were investigated. Agglomeration is almost finished in 8h, se...By means of Malvern laser particle size analyzer and scanning electron microscopy, the influences of seed size and number on agglomeration in Bayer process were investigated. Agglomeration is almost finished in 8h, seeds, below 5μm, especially below 2μm, gather together rapidly and almost disappear in 8h. In the same supersaturation of aluminate solution and seed size, the smaller the number of seed is, the bigger the degree of agglomeration is. With the same primary number of seed, the agglomeration of larger seed is superior to that of small seed, and the agglomeration does not happen among the coarse seeds. The agglomeration mainly happens among fine particles, and the combinations among the fine particles are unconsolidated.展开更多
Indirect heating and intensified digestion technology can be applied to reduce greatly the energy consumption in Bayer process of diasporic bauxite. A great advantage of two-stream process is to avoid or reduce effici...Indirect heating and intensified digestion technology can be applied to reduce greatly the energy consumption in Bayer process of diasporic bauxite. A great advantage of two-stream process is to avoid or reduce efficiently serious scaling problem of bauxite slurry on indirect heating surface, which certainly happens in the single stream process and brings about great troubles to the indirect heating. As a result of a great number of experiments and the theoretical analysis, a new lime adding technology for the two-stream digestion process is developed in this paper that lime is added into spent liquor stream instead of bauxite slurry, which is more suitable to the two-stream process of diasporic bauxite. The influences of the new lime addition technology on preheating and digestion process were discussed. It was deduced that the new technology can be used efficiently in the two-stream process of non-diasporic bauxite.展开更多
A new technology was developed to recover V2O5 from Bayer spent liquor by ion exchange.The experimental results show that in the conditions of 105℃ and 0.20-0.25 mass ratios between CaO in lime and Al2O3 in spent liq...A new technology was developed to recover V2O5 from Bayer spent liquor by ion exchange.The experimental results show that in the conditions of 105℃ and 0.20-0.25 mass ratios between CaO in lime and Al2O3 in spent liquor, the precipitation rate of vanadium in Bayer liquor is more than 85%.The vanadium-bearing precipitation is leached by NaHCO3 solution.The leaching rate of vanadium can reach 85% in the conditions of 95℃, 40 g·L-1 of NaHCO3 concentration, and ventilating of CO2.The 201 × 7 type of resin has good adsorption effect on vanadium in the leaching solution.The adsorption rate is more than 94% with the flow rate of 0.09 mL·min-1·g-1 of leaching solution and the temperature of 40-50℃.By using 3 mol·L-1 of NaOH to desorb the saturated resin after adsorption at 40-50℃, a solution with more than 5 g·L-1 of V2O5 can be obtained.After roasting ammonium metavanadate that precipitates from the desorption solution when NH4Cl is added at the temperature of 500-550℃ for 2 h, V2O5 with more than 99% of purity is obtained.展开更多
Fine Al（OH）3 crystals were aggregated from supersaturated aluminate solution in the batch reaction tanks. By means of laser particle size analyzer and scanning electron microscopy, the influences of temperature and ...Fine Al（OH）3 crystals were aggregated from supersaturated aluminate solution in the batch reaction tanks. By means of laser particle size analyzer and scanning electron microscopy, the influences of temperature and initial molar ratio of Na2O to Al2O3 （aK） on agglomeration of fine seed in Bayer process were investigated. The results show that agglomeration is almost finished in 8 h, and seeds with size less than 2 μm are easily aggregated together, and almost disappear in 8 h under the optimal process conditions. In the aluminate solution with the same moderate initial aK, when the reaction temperature reaches 75 ℃, the secondary nucleation does not occur, and the effect of agglomeration is better. And at the same reaction temperature, when the initial aK is 1.62, the initial supersaturation of aluminate solution is moderate, the binders on the surfaces of the seed are enough to maintain the agglomeration process, and the agglomeration degree is better. From SEM images, agglomeration mainly occurs in the fine particles, the combinations among the fine particles are loose and the new formed coarse crystal shapes are irregular.展开更多
采用工业废渣复配材料以及SY添加剂对拜耳法赤泥进行固化处理,通过承载比(CBR)、无侧限抗压强度(UCS)、重结晶和吸水率试验,研究了废渣固化赤泥用作道路材料的可行性,进一步对比分析了废渣固化材料及SY添加剂掺量变化对固化赤泥体系性...采用工业废渣复配材料以及SY添加剂对拜耳法赤泥进行固化处理,通过承载比(CBR)、无侧限抗压强度(UCS)、重结晶和吸水率试验,研究了废渣固化赤泥用作道路材料的可行性,进一步对比分析了废渣固化材料及SY添加剂掺量变化对固化赤泥体系性能的影响规律.结果表明:废渣固化赤泥体系在不同压实度下的CBR值均可达到25%以上,7 d UCS值超过3 MPa,且随废渣固化材料掺量的增加而逐渐增大.此外,废渣固化赤泥体系的重结晶情况良好,吸水率较低,有利于长期性能的稳定.而SY添加剂的使用能使废渣固化赤泥体系的性能得到进一步增强.当SY添加剂掺量为0.1%时,废渣固化赤泥体系的物理力学性能即可得到明显提高.展开更多
文摘The control techniques for indirect heating digestion in Bayer process of alumina production were researched and developed. They include controlling chemical composition of slurry to be digested and controlling digestion status and energy consumption. Very good performances and technical and technical and economical figures for digestion process have been obtained by carefully applying these comprehensive control techniques in Pingguo alumina refinery.
基金the financial supports from the National Natural Science Foundation of China(No.51904052)the Chongqing Research Program of Basic Research and Frontier Technology,China(No.cstc2020jcyjmsxm X0476)+1 种基金the Science and Technology Research Program of Chongqing Municipal Education Commission,China(No.KJQN201901508)the Graduate Science and Technology Innovation Training Program of Chongqing University of Science and Technology,China(No.YKJCX2020201)。
文摘Thermodynamic diagrams of Na−S−Fe−H_(2)O system were constructed to analyze the behavior of sulfur and iron in the Bayer process.After digestion,iron mainly exists as Fe_(3)O_(4) and Fe_(2)O_(3) in red mud,and partial iron transfers into solution as Fe(OH)_(3)^(−),HFeO_(2)^(−),Fe(OH)_(4)^(−)and Fe(OH)_(4)^(2−).The dominant species of sulfur is S^(2−),followed by SO_(4)^(2−),and then SO_(3)^(2−)and S_(2)O_(3)^(2−).The thermodynamic analysis is consistent with the iron and sulfur species distribution in the solution obtained by experiments.When the temperature decreases,sulfur and iron can combine and precipitate.Controlling low potential and reducing temperature are beneficial to removing them from the solution.XRD patterns show that NaFeS_(2)·2H_(2)O,FeS and FeS_(2) widely appear in red mud and precipitates of pyrite and high-sulfur bauxite digestion solution.Thermodynamic analysis can be utilized to guide the simultaneous removal of sulfur and iron in the Bayer process.
文摘A quantitative Fourier transform infrared (FTIR) technique mas established by comparison with chemical analysis and quantitative X-ray diffraction (XRD) analysis. By the quantitative FTIR analysis of bauxite during dissolution , the process of dissolution and precipitation of silica was found to occur in three stages. In the first stage, there was no precipitation of desilication product (DSP). All the silica dissolved from kaolinite went into the solution. In the second stage, the silica concentration in solution attained a maximum and then dropped very quickly. The precipitation of DSP was the main cause of the reduction of the silica concentration in solution. In the third stage, the concentration of DSP reached a constant level. The dissolution and precipitation process gradually attained an equilibrium. The mechanism of silica dissolution and DSP precipitation was discussed on the basis of the FTIR quantitative analysis of kaolinite and DSP in bauxite.
基金Project(51374239)supported by the National Natural Science Foundation of China
文摘Digesting aluminum-bearing minerals and converting ferric oxide to magnetite simultaneously in Bayer digestion process is crucially important to deal with high-iron diasporic bauxite economically for alumina production.The reaction behaviors of hydrothermal reduction of ferric oxide in alkali solution were studied by both thermodynamic calculation and experimental investigation.The thermodynamic calculation indicates that Fe3O4 can be formed by the conversion of Fe2O3 at proper redox potentials in alkaline solution.The experimental results show that the formation ratio of Fe3O4 either through the reaction of Fe and Fe2O3 or through the reaction of Fe and H2O in alkaline aqueous solution increases remarkably with raising the temperature and alkali concentration,suggesting that Fe（OH）3- and Fe（OH）4- form by dissolving Fe and Fe2O3,respectively,in alkaline aqueous solution and further react to form Fe3O4.Moreover,aluminate ions have little influence on the hydrothermal reduction of Fe2O3 in alkaline aqueous solution,and converting iron minerals to magnetite can be realized in the Bayer digestion process of diasporic bauxite.
基金support provided by the National Natural Science Foundation of China(No.52104353)。
文摘The conversion mechanism of Al-goethite under the action of different additives(lime or reductant for typical or reductive Bayer digestion)was investigated by thermodynamic calculation,XRD,and SEM-EDS.The results show that the formation of Fe-substituted hydrocalumite is crucial to converting Al-goethite to hematite during Bayer digestion by adding lime.However,the conversion proceeds more easily under the action of reductant due to the rapid formation of magnetite.Additionally,Bayer liquor composition significantly affects the product composition and also the conversion rate of Al-goethite.Compared to typical Bayer digestion with Al-goethite containing gibbsitic bauxite as raw material,the red mud yield of reductive Bayer digestion decreases from 39.02%to 31.19%,and the grade of TFe in red mud increases from 41.66%to 53.80%.
基金Project(G19990649) supported by the National Key Fundamental Research and Development Programof China project(59874031) supported by the National Natural Science Foundation of China
文摘By means of Malvern laser particle size analyzer and scanning electron microscopy, the influences of seed size and number on agglomeration in Bayer process were investigated. Agglomeration is almost finished in 8h, seeds, below 5μm, especially below 2μm, gather together rapidly and almost disappear in 8h. In the same supersaturation of aluminate solution and seed size, the smaller the number of seed is, the bigger the degree of agglomeration is. With the same primary number of seed, the agglomeration of larger seed is superior to that of small seed, and the agglomeration does not happen among the coarse seeds. The agglomeration mainly happens among fine particles, and the combinations among the fine particles are unconsolidated.
文摘Indirect heating and intensified digestion technology can be applied to reduce greatly the energy consumption in Bayer process of diasporic bauxite. A great advantage of two-stream process is to avoid or reduce efficiently serious scaling problem of bauxite slurry on indirect heating surface, which certainly happens in the single stream process and brings about great troubles to the indirect heating. As a result of a great number of experiments and the theoretical analysis, a new lime adding technology for the two-stream digestion process is developed in this paper that lime is added into spent liquor stream instead of bauxite slurry, which is more suitable to the two-stream process of diasporic bauxite. The influences of the new lime addition technology on preheating and digestion process were discussed. It was deduced that the new technology can be used efficiently in the two-stream process of non-diasporic bauxite.
文摘A new technology was developed to recover V2O5 from Bayer spent liquor by ion exchange.The experimental results show that in the conditions of 105℃ and 0.20-0.25 mass ratios between CaO in lime and Al2O3 in spent liquor, the precipitation rate of vanadium in Bayer liquor is more than 85%.The vanadium-bearing precipitation is leached by NaHCO3 solution.The leaching rate of vanadium can reach 85% in the conditions of 95℃, 40 g·L-1 of NaHCO3 concentration, and ventilating of CO2.The 201 × 7 type of resin has good adsorption effect on vanadium in the leaching solution.The adsorption rate is more than 94% with the flow rate of 0.09 mL·min-1·g-1 of leaching solution and the temperature of 40-50℃.By using 3 mol·L-1 of NaOH to desorb the saturated resin after adsorption at 40-50℃, a solution with more than 5 g·L-1 of V2O5 can be obtained.After roasting ammonium metavanadate that precipitates from the desorption solution when NH4Cl is added at the temperature of 500-550℃ for 2 h, V2O5 with more than 99% of purity is obtained.
基金Project(2005CB623702)supported by the Major State Basic Research and Development Program of ChinaProject(20476107) supported by the National Natural Science Foundation of China
文摘Fine Al（OH）3 crystals were aggregated from supersaturated aluminate solution in the batch reaction tanks. By means of laser particle size analyzer and scanning electron microscopy, the influences of temperature and initial molar ratio of Na2O to Al2O3 （aK） on agglomeration of fine seed in Bayer process were investigated. The results show that agglomeration is almost finished in 8 h, and seeds with size less than 2 μm are easily aggregated together, and almost disappear in 8 h under the optimal process conditions. In the aluminate solution with the same moderate initial aK, when the reaction temperature reaches 75 ℃, the secondary nucleation does not occur, and the effect of agglomeration is better. And at the same reaction temperature, when the initial aK is 1.62, the initial supersaturation of aluminate solution is moderate, the binders on the surfaces of the seed are enough to maintain the agglomeration process, and the agglomeration degree is better. From SEM images, agglomeration mainly occurs in the fine particles, the combinations among the fine particles are loose and the new formed coarse crystal shapes are irregular.
文摘采用工业废渣复配材料以及SY添加剂对拜耳法赤泥进行固化处理,通过承载比(CBR)、无侧限抗压强度(UCS)、重结晶和吸水率试验,研究了废渣固化赤泥用作道路材料的可行性,进一步对比分析了废渣固化材料及SY添加剂掺量变化对固化赤泥体系性能的影响规律.结果表明:废渣固化赤泥体系在不同压实度下的CBR值均可达到25%以上,7 d UCS值超过3 MPa,且随废渣固化材料掺量的增加而逐渐增大.此外,废渣固化赤泥体系的重结晶情况良好,吸水率较低,有利于长期性能的稳定.而SY添加剂的使用能使废渣固化赤泥体系的性能得到进一步增强.当SY添加剂掺量为0.1%时,废渣固化赤泥体系的物理力学性能即可得到明显提高.
