摘要
为合理评估变频电机绕组的绝缘性能,IEC建议采用脉冲方波电压开展测试并且选择合适的脉冲参数以减小电压波形带来的测试偏差。通过对脉冲电源波形参数选择的分析,研制了一台基于桥式固态开关器件的直接输出式脉冲方波电源,给出了脉冲变换主回路暂态参数的设计方法。波形测试结果表明该脉冲方波电源能够输出具有对称脉冲边沿特性的脉冲方波,通过控制半导体固态开关和调节充放电参数能得到最短脉冲边沿时间20 ns、最大重复频率20 kHz、最高电压幅值10 kV的对称脉冲波形,耐电晕寿命测试结果与相关研究结论一致。该脉冲电源运行可靠、结构简单,输出波形稳定,可用于开展脉冲电压条件下变频电机绝缘性能评估工作。
In order to evaluate the insulation performance of converter motor windings reasonably,the International Electrotechnical Commission (IEC) released two standards and recommended to evaluation the insulation by using repetitive impulsive wave voltage. The voltage parameters can significantly influence insulation lifetime,and thus,voltage parameters should be carefully controlled during the experiments. Firstly,the waveform parameters selection method of pulse power supply is analyzed in this paper,and a direct output pulse square wave power supply based on bridge solid state switch is developed,and the design method of transient parameters of impulse conversion main circuit is given. The measurement results of waveform tests show that this generator can output pulse square wave with symmetrical pulse edge characteristics. By controlling the semi-solid-state switch and adjusting the charge/discharge parameters,a symmetrical pulse square wave with the shortest pulse edge time of 20 ns,the maximum continuous repetition frequency of 20 kHz and the maximum voltage amplitude of 10 kV can be obtained,and the corona-resistant life test results are consistent with the relevant research conclusions. This generator is reliable in operation,simple in structure and stable in output waveform. It can be used to evaluate the insulation performance of convertor motor under pulse voltage conditions.
作者
王剑
连利波
刘洋
唐明
Wang Jian;Lian Libo;Liu Yang;Tang Ming(Sichuan Energy Internet Research Institute,Tsinghua University,Chengdu 610213,China;Institute of Aeronautics and Engineering,Civil Aviation Flight University of China,Guanghan 618307,Sichuan,China)
出处
《电测与仪表》
北大核心
2020年第15期129-134,共6页
Electrical Measurement & Instrumentation
关键词
变频电机
绝缘测试
脉冲方波
对称脉冲边沿
半导体固态开关
converter motors
insulation evaluation
impulsive square wave
symmetrical pulse edge
semi-solid-state switch
