摘要
为对不同堆肥工艺堆肥全过程关键参数进行实时动态分析,该研究以牛粪便和玉米秸秆为原料,进行规模化槽式和膜覆盖好氧堆肥,采集堆肥全过程样本,分析了2种堆肥技术堆肥全过程中含水率、有机质含量和碳氮比等关键参数的变化,并结合Local PLS算法建立了2种堆肥技术堆肥全过程中上述参数的通用速测模型,得出以下结果:1)2种主要工艺关键参数数值及变化规律均不同,且在整个堆肥过程中有显著性变化(P<0.05);2)所建立的Local PLS模型的RPD(Ratio of Prediction to Deviation)为4.47,RSD(Relative Standard Deviation)为3.37%,可达到很好的预测效果;有机质含量和碳氮比的R_P^2分别为0.74和0.77,RPD大于1.5,RSD小于10%,模型可用于定量预测;近红外预测值与实测值随堆肥时间的变化趋势具有较好的一致性,可实现规模化堆肥过程中关键参数的实时分析。
Biomass resources,including crop straw and livestock manure,can usually serve as advantageous raw materials to produce organic fertilizer.The utilization of these resources can be achieved in aerobic composting technology.Currently,trough composting is the main large-scale composting technology in China,due to its large processing capacity,low investment cost,and short composting cycle.As a new type of composting technology,membrane-covered composting refers to a semi-permeable membrane to cover the surface of the fermentation trough.Much attention has gained due to its high efficiency,adaptability,energy saving,easy operation,and reduction of greenhouse gas.However,the composting is normally associated with the complex physical and chemical changes under the action of microorganisms,particularly when affected by some process parameters,such as temperature,moisture content(MC),organic matter content(OM),and carbon-nitrogen(C/N)ratio.Specifically,the sample complexity varied in different technologies during composting process.It is necessary to rapidly detect the processing parameters in real time during the whole composting process,in order to fully optimize composting process for the composting quality.Near infrared spectroscopy(NIRS)can serve as a promising analytical technology in this case.However,most studies focused on a specific model for a certain composting technology.Since a general model suitable for different composting technologies was built using partial least squares(PLS)method,it is inevitable to bring some problems,such as the number increase of latent variables,model overfitting,and low prediction accuracy.Local PLS algorithm can be expected to save calculation time and improve the accuracy of the models.This study aims to dynamic analyze composting parameters in real-time for various composting technologies using FT-NIR spectroscopy combined with Local PLS method.Dairy manure and corn stalks were used as raw materials for the large-scale trough and membrane-covered aerobic composting.100 samples were collected for each composting technology.The key physicochemical parameters were analyzed,such as MC,OM,and C/N ratio,during the composting process.A FT-NIR spectrometer was used to obtain the infrared spectra of samples.Local PLS algorithm was used to establish the universal rapid measurement models of processing parameters during the whole composting process in two composting techniques.The results showed that:1)The changes of key parameters in the whole composting process varied greatly in an individual trough or membrane-covered composting,indicating significant variation in the processing(P<0.05);2)The established Local PLS model demonstrated,excellent prediction for the MC with the R_P^2 value of 0.95,RPD value of 4.47,and RSD value of 3.37%,as well approximate quantitative prediction for the OM and C/N ratio with the R_P^2 value of 0.74 and 0.77,RPD value above 1.5,and RSD less than 10%.NIR-prediction has also a good agreement with the measured in the change trends during the composting processing.The proposed algorithm can provide a promising potential to the real-time dynamic analysis of key parameters in the large-scale trough and membrane-covered composting process.
作者
黄圆萍
沈广辉
廖科科
吴亚蓝
韩鲁佳
杨增玲
Huang Yuanping;Shen Guanghui;Liao Keke;Wu Yalan;Han Lujia;Yang Zengling(College of Engineering,China Agricultural University,Beijing 100083,China)
出处
《农业工程学报》
EI
CAS
CSCD
北大核心
2020年第13期195-202,共8页
Transactions of the Chinese Society of Agricultural Engineering
基金
国家奶牛产业技术体系项目(CARS36)
教育部创新团队发展计划项目(IRT-17R105)。
关键词
近红外
堆肥
算法
过程分析
槽式堆肥
膜覆盖堆肥
关键参数
Local
PLS
near infrared spectroscopy
composting
algorithm
process analysis
trough composting
membrane-covered composting
keyparameters
Local PLS
