The accuracy of fluctuating pressure test in wind tunnel is affected by the tube system. By employing contradistinctive experimental method, systematic study was conducted to investigate the effects of the tube system...The accuracy of fluctuating pressure test in wind tunnel is affected by the tube system. By employing contradistinctive experimental method, systematic study was conducted to investigate the effects of the tube system on fluctuating pressure. The analyzed tube system parameters include tube length, inside diameter, curvature, deflection angle, thickness, material, restrictor length,restrictor inside diameter, and restrictor place. It is found that all the tube system parameters mentioned above except tube curvature have non-negligible effects on fluctuating pressure. Based on the research results, test methods were presented for the fluctuating pressure measurement in low-speed wind tunnel, which can obviously improve the data accuracy but not lose test efficiency. The effectiveness of the method is verified by the wind tunnel test.展开更多
An experimental study was conducted on the interactions of shock wave/turbulence or laminar boundary layer caused by fin-type protuberance, as the lack of detailed understanding of fluctuating pressure loads inside an...An experimental study was conducted on the interactions of shock wave/turbulence or laminar boundary layer caused by fin-type protuberance, as the lack of detailed understanding of fluctuating pressure loads inside and outside the laminar or turbulence boundary layer separation region in hypersonic flow. The changes of fluctuating pressure in separation region were focused on in this paper. The study shows that the existence of fin changes flowfiled on the plate significantly. The laminar boundary layer separation occurs earlier and the separation region is more extensive. Similar flow is observed between a couple of measurement points outside the laminar separation region. However, there are significant differences between the flow inside and outside the separation region. The level of fluctuating pressure of laminar boundary layer is smaller than that in turbulent case. Even so, in laminar case, the peak fluctuating pressure still reaches a high level. Therefore, the structural influence （damage and/or early fatigue） of fluctuating pressure loads caused by the laminar boundary layer separation should not be ignored.展开更多
This study conducts a comparative analysis between detached eddy simulation(DES)and Unsteady Reynolds-averaged Navier-Stokes(URANS)models for simulating pressure fluctuations in a stilling basin,aiming to assess the U...This study conducts a comparative analysis between detached eddy simulation(DES)and Unsteady Reynolds-averaged Navier-Stokes(URANS)models for simulating pressure fluctuations in a stilling basin,aiming to assess the URANS mode’s performance in modeling pressure fluctuation.The URANS model predicts accurately a smoother flow field and its time-average pressure,yet it underestimates the root mean square of pressure(RMSP)fluctuation,achieving approximately 70%of the results predicted by DES model on the bottom floor of the stilling basin.Compared with DES model’s results,which are in alignment with the Kolmogorov−5/3 law,the URANS model significantly overestimates low-frequency pulsations,particularly those below 0.1 Hz.We further propose a novel method for estimating the RMSP in the stilling basin using URANS model results,based on the establishment of a quantitative relationship between the RMSP,time-averaged pressure,and turbulent kinetic energy in the boundary layer.The proposed method closely aligns with DES results,showing a mere 15%error level.These findings offer vital insights for selecting appropriate turbulence models in hydraulic engineering and provide a valuable tool for engineers to estimate pressure fluctuation in stilling basins.展开更多
Centrifugal pumps are extensively employed in ocean engineering,such as ship power systems,water transportation,and mineral exploitation.Pressure fluctuation suppression is essential for the operation stability and se...Centrifugal pumps are extensively employed in ocean engineering,such as ship power systems,water transportation,and mineral exploitation.Pressure fluctuation suppression is essential for the operation stability and service life of the centrifugal pump.In this paper,a new method of bionic structure is proposed for the blade surface of a centrifugal pump,which is inspired by the fish scale and comprises a leading edge,a trailing edge,and two symmetrical side edges.This fish scale structure is applied to the blade pressure and suction surfaces,and an impeller with a fish scale structure is constructed.A test rig for a centrifugal pump is developed to determine the pressure fluctuation in the pump with a prototype impeller and fish scale structure impeller.Results reveal that the dominant frequency of pressure fluctuation in volute is the blade passing frequency(f_(bpf))of 193.33 Hz,which is triggered by the interaction between the tongue and the impeller.The bionic structure of the fish scale effectively suppresses the pressure fluctuation amplitude at f_(bpf).From flow rates of 0.6 Q_(d)to 1.2 Q_(d),the average suppressions in pressure fluctuation amplitudes at f_(bpf)are 20.98%,5.85%,19.20%,and 25.77%.展开更多
Using four types of stilling basin models,this paper studies frequency characteris- tics of the fluctuating pressure acting on the stilling basin apron when Froude number is not greater than 4.5.The testing results sh...Using four types of stilling basin models,this paper studies frequency characteris- tics of the fluctuating pressure acting on the stilling basin apron when Froude number is not greater than 4.5.The testing results show that the frequency of fluctuating pressure,f_s in the ranges of 0. 4Hz≤f_s≤1.1Hz.0.2Hz≤f_s≤2.5Hz and 0.4Hz≤f_s≤3.3Hz.can be used as the design frequency corresponding to three patterns of hydraulic jump.The reliability of f_s for three jump patterns is all nearly equal to 90%.展开更多
A new view of the spatial relation between fluctuating wall pressure and near-wall streamwise vortices （NWSV） is proposed for wall bounded turbulent flow by use of the direct numerical simulation （DNS） database. T...A new view of the spatial relation between fluctuating wall pressure and near-wall streamwise vortices （NWSV） is proposed for wall bounded turbulent flow by use of the direct numerical simulation （DNS） database. The results show that the wall region with low pressure forms just below the strong NWSV, which is mostly associated with the overhead NWSV. The wall region with high pressure forms downstream of the NWSV, which has a good correspondence with the downwash of the fluids induced by the upstream NWSV. The results provide a significant basis for the detection of NWSV.展开更多
This study investigates high-amplitude Extreme Wall Pressure fluctuation Events(EWPEs)in Shock wave/Turbulent Boundary Layer Interactions(STBLIs)through the conditional sampling of direct numerical simulation database...This study investigates high-amplitude Extreme Wall Pressure fluctuation Events(EWPEs)in Shock wave/Turbulent Boundary Layer Interactions(STBLIs)through the conditional sampling of direct numerical simulation databases.The aim is to evaluate the effect of STBLIs and their strength on the statistical properties and associated turbulent structures of EWPEs using the conditional-averaging and clustering method.The temporal statistical results show that the occurrence probability and contribution ratio of EWPEs decrease downstream of strong STBLI,but their duration and interval time increase.Regarding two-dimensional wall pressure structures,the large population of small-scale structures becomes more elongated,but strong interactions induce a greater number of large-scale structures.The pairing of wall pressure events with a higher occurrence probability is verified by the joint probability density functions.Conditional analysis reveals that,as the interaction strength increases,the ejection motion associated with positive events occurs farther downstream and the spanwise vortex core locating above negative events is lifted up along the wall-normal direction.Moreover,analysis associates the paired wall pressure events with the sweep,ejection,and swirl motions in STBLIs,where hairpin eddies play an important role in the formation of positive-negative paired wall pressure structures.展开更多
Open cavities with different door-opening angles are investigated using high-speed schlieren visualization and dynamic pressure measurements in hypersonic flow with a freestream Mach number of 6.With the help of numer...Open cavities with different door-opening angles are investigated using high-speed schlieren visualization and dynamic pressure measurements in hypersonic flow with a freestream Mach number of 6.With the help of numerical simulations,the shear layer deformation and pressure increase in the cavities due to the impingement of the door-leading-edge shocks are identified via comparison with those in the cavity without doors.As the door-opening angle decreases from 90°,the shear layer above the forepart of the cavity is gradually raised by the high pressure in the cavity.When the door-opening angle decreases to 30°and 15°,the boundary layer on the upstream flat plate of the cavity separates,and separation shock is observed.The doors enhance the instability of the cavity flow and increase the pressure fluctuations in the cavities.A new oscillation pattern,referred to as coupled oscillation,is observed in the cases with separation on the upstream flat plate,in which the separation shock oscillates at the same dominant frequency as the flow inside the cavity.Compared with the cavity without doors,this coupled oscillation causes a lower oscillation frequency and a larger overall sound pressure level.Cross-correlation analyses between pressure signals indicate that the disturbances generated at the trailing edge of the cavity can propagate to the separation on the upstream flat plate and cause coupled oscillation of the separation shock.The fundamental frequencies of the coupled oscillations can be normalized to approximately the same Strouhal number as that of the cavity without doors.These findings support that the oscillation mechanisms of hypersonic cavities without and with doors are primarily dominated by acoustic feedback.展开更多
The pressure fluctuation in the flow passage of both impeller and casing is addressed on design condition. The initial conditions for the unsteady turbulent simulation are resulted from the steady calculations, and th...The pressure fluctuation in the flow passage of both impeller and casing is addressed on design condition. The initial conditions for the unsteady turbulent simulation are resulted from the steady calculations, and the three dimensional unsteady turbulent simulation concerning the rotor-stator interaction is executed by a Navier-Stoke solver embedded with k -ε turbulence model and with appropriate moving interface boundary conditions. Detecting points are distributed in the flow passage in different radial and circumferential positions to capture the static pressure fluctuation character for one cycle of the impeller. The time-domain spectrums show that the static pressure curves are periodic and have five peaks and five valleys. With the radius increasing, the pressure fluctuation peak-to-peak values in the impeller are increasing, and reach the maximum value on the interface. In the casing flow passage, those values are about 7% of local static pressure except some ones near the tongue. The values become decreasingly in the diffuser pipe. The frequency spectrums transformed by fast Fourier transform （FFT） show that the dominant frequency is approximate with the blade passing frequency, and the pressure fluctuations in impeller passage have high frequency content while those in casing ones have no such information.展开更多
Frequent shifts of output and operating mode require a pump turbine with excellent stability. Current researches show that large partial flow conditions in pump mode experience positive-slope phenomena with a large he...Frequent shifts of output and operating mode require a pump turbine with excellent stability. Current researches show that large partial flow conditions in pump mode experience positive-slope phenomena with a large head drop. The pressure fluctuation at the positive slope is crucial to the pump turbine unit safety. The operating instabilities at large partial flow conditions for a pump turbine are analyzed. The hydraulic performance of a model pump turbine is tested with the pressure fluctuations measured at unstable operating points near a positive slope in the performance curve. The hydraulic performance tests show that there are two separated positive-slope regions for the pump turbine, with the flow discharge for the first positive slope from 0.85 to 0.91 times that at the maximum efficiency point. The amplitudes of the pressure fluctuations at these unstable large partial flow conditions near the first positive slope are much larger than those at stable operating condtions. A dominant frequency is measured at 0.2 times the impeller rotational frequency in the flow passage near the impeller exit, which is believed to be induced by the rotating stall in the flow passage of the wicket gates. The test results also show hysteresis with pressure fluctuations when the pump turbine is operated near the first positive slope. The hysteresis creates different pressure fluctuations for those operation points even though their flow rates and heads are similar respectively. The pressure fluctuation characteristics at large partial flow conditions obtained by the present study will be helpful for the safe operation of pumped storage units.展开更多
During the exploitation of offshore oil and gas,it is easy to form severe slugging which can cause great harm in the riser connecting wellheads and offshore platform preprocessing system.The flow pattern and pressure ...During the exploitation of offshore oil and gas,it is easy to form severe slugging which can cause great harm in the riser connecting wellheads and offshore platform preprocessing system.The flow pattern and pressure fluctuation of severe slugging were studied in an experimental simulation system with inner diameter of 0.051 m.It is found that severe slugging can be divided into three severe slugging regimes：regime I at low gas and liquid flow rates with large pressure fluctuation,intermittent flow of liquid and gas in the riser,and apparent cutoff of liquid phase,regime II at high gas flow rate with non-periodic fluctuation and discontinuous liquid outflow and no gas cutoff,regime III at high liquid flow rate with degenerative pressure fluctuation in form of relatively stable bubbly or plug flow.The results indicate that severe slugging still occurs when the declination angle of pipeline is 0,and there are mainly two kinds of regimes：regime I and regime II.As the angle increases,the formation ranges of regime I and regime III increase slightly while that of regime II is not affected.With the increase of gas superficial velocity and liquid superficial velocity,the pressure fluctuation at the bottom of riser increases initially and then decreases.The maximum value of pressure fluctuation occurs at the transition boundary of regimes I and II.展开更多
In order to investigate the effect of sampling frequency and time on pressure fluctuations, the three-dimensional unsteady numerical simulations were conducted in a circulating water pump. Through comparison of turbul...In order to investigate the effect of sampling frequency and time on pressure fluctuations, the three-dimensional unsteady numerical simulations were conducted in a circulating water pump. Through comparison of turbulence models with hydraulic performance experiment, SST k-co model was confirmed to study the rational determination of sampling frequency and time better. The Fast Fourier Transform （FFT） technology was then adopted to process those fluctuating pressure signals obtained. On these bases, the characteristics of pressure fluctuations acting on the tongue were discussed. It is found that aliasing errors decrease at higher sampling frequency of 17 640 Hz, but not at a lower sampling frequency of 1 764 Hz. Correspondingly, an output frequency range ten-times wider is obtained at 17 640 Hz. Compared with 8R, when the sampling time is shorter, the amplitudes may be overvalued, and the frequencies and amplitudes of low-frequency fluctuations can not be well predicted. The frequencies at the tongue are in good agreement with the values calculated by formula and the frequency compositions less than the blade passing frequency are accurately predicted.展开更多
Pressure fluctuation in the submerged circulative impinging stream reactor （SCISR） is studied by measuring the dynamic pressure with micro pressure sensors of high accuracy, with water as the process material. Exper...Pressure fluctuation in the submerged circulative impinging stream reactor （SCISR） is studied by measuring the dynamic pressure with micro pressure sensors of high accuracy, with water as the process material. Experimental results show that the maximum amplitude of fluctuation can be up to about 1.6kPa. On the power spectra the fluctuation is relatively concentrated in the range of 〈1000Hz, with some weak peeks in acoustic wave range. The space profile of intensive fluctuation region in the reactor is determined. The region is found to take the form of a couple truncated cones of empty core, with coincided bottoms, and is symmetrical with respect to the impinging plane and approximately symmetrical about the axis, essentially independent of u0. The integral intensity of fluctuation increases as the impinging velocity, Uo increasing.展开更多
The pressure fluctuation caused by unsteady flow in runner is one of the main reasons of vibration for a large Francis hydraulic turbine. It directly affects the steady operation of the hydraulic turbine unit. The exi...The pressure fluctuation caused by unsteady flow in runner is one of the main reasons of vibration for a large Francis hydraulic turbine. It directly affects the steady operation of the hydraulic turbine unit. The existing research of the pressure fluctuation in hydraulic turbine mainly focuses on the unsteady flow in draft tube. Accurate distribution of pressure fluctuations inside a runner is not very clear. In this paper, the numerical method for predicting the pressure fluctuations in runner is investigated and the numerical simulation is performed for a large Francis hydraulic turbine. It is proved that the combination of shear-stress transport（SST） k-o） turbulence model and pressure-implicit with splitting of operators（PISO） algorithm could give more reliable prediction of pressure fluctuations in runner. The frequencies of pressure fluctuations in runner are affected by the flow in guide vane and the flow in draft tube The first dominant frequency is significantly determined by the flow in draft tube, especially at part load condition. This frequency is approximately equal to one-third of the runner rotating frequency. The evident second dominant frequency is exactly equal to the guide vane passing frequency. The peak-to-peak amplitudes of pressure fluctuations in runner at small guide vane open angle are larger than that at large open angle at the same operating head. The amplitudes at points on blade pressure surface are generally greater than that on suction surface. The research results could be used to direct the hydraulic design and operation stability improvement of a large Francis hydraulic turbine.展开更多
Pressure fluctuation may cause high amplitude of vibration of double-suction centrifugal pumps, but the impact of impeller stagger angles is still not well understood. In this paper, pressure fluctuation experiments a...Pressure fluctuation may cause high amplitude of vibration of double-suction centrifugal pumps, but the impact of impeller stagger angles is still not well understood. In this paper, pressure fluctuation experiments are carried out for five impeller configurations with different stagger angles by using the same test rig system. Results show that the stagger angles exert negligible effects on the characteristics of head and efficiency. The distributions of pressure fluctuations are relatively uniform along the suction chamber wall, and the maximum pressure fluctuation amplitude is reached near the suction inlet tongue region. The pressure fluctuation characteristics are affected largely by impeller rotation, whose dominant frequencies include impeller rotation frequency and its harmonic frequencies, and half blade passage frequency. The stagger angle exerts a small effect on the pressure fluctuations in the suction chamber while a great effect on the pressure fluctuation in volute casing, especially on the aspect of decreasing the amplitude on blade passage frequency. Among the tested cases, the distribution of pressure fluctuations in the volute becomes more uniform than the other impeller configurations and the level of pressure fluctuation may be reduced by up to 50% when the impeller stagger angle is close to 24° or 360°.The impeller structure pattern needs to be taken into consideration during the design period, and the halfway staggered impeller is strongly recommended.展开更多
This study established a 3D finite element model for 15# hydropower house of the Three Gorges Project (TGP) and performed a nonlinear dynamic analysis under pressure fluctuation. In this numerical model, the stiffness...This study established a 3D finite element model for 15# hydropower house of the Three Gorges Project (TGP) and performed a nonlinear dynamic analysis under pressure fluctuation. In this numerical model, the stiffness degradation in tension for concrete was considered on the basis of the continuum isotropic damage theory. Natural vibration frequencies of the damaged and undamaged structures were compared after static water pressure was applied. Then a study was further conducted on forced vibration of the powerhouse with pre-existing damages under pressure fluctuation that acts on the flow passage; displacement, velocity and acceleration of the important structural members were afterwards presented and checked. Numerical results show that tensile damages in concrete surrounding the spiral case only exert significant impact upon the dynamic characteristics of substructure but show little effect on the superstructure. Nevertheless vibrations of the powerhouse are still under the recommended vibration limits.展开更多
Calculation grid and turbulence model for numerical simulating pressure fluctuations in a high-speed train tunnel are studied through the comparison analysis of numerical simulation and moving model test.Compared the ...Calculation grid and turbulence model for numerical simulating pressure fluctuations in a high-speed train tunnel are studied through the comparison analysis of numerical simulation and moving model test.Compared the waveforms and peak-peak values of pressure fluctuations between numerical simulation and moving model test,the structured grid and the SST k-ωturbulence model are selected for numerical simulating the process of high-speed train passing through the tunnel.The largest value of pressure wave amplitudes of numerical simulation and moving model test meet each other.And the locations of the largest value of the initial compression and expansion wave amplitude of numerical simulation are in agreement with that of moving model test.The calculated pressure at the measurement point fully conforms to the propagation law of compression and expansion waves in the tunnel.展开更多
It has been shown that much dynamic information is hidden in the pressure fluctuation signals of a gas-solid fluidized bed. Unfortunately, due to the random and capricious nature of this signal, it is hard to realize ...It has been shown that much dynamic information is hidden in the pressure fluctuation signals of a gas-solid fluidized bed. Unfortunately, due to the random and capricious nature of this signal, it is hard to realize reliable analysis using traditional signal processing methods such as statistical analysis or spectral analysis, which is done in Fourier domain. Information in different frequency band can be extracted by using wavelet analysis. On the evidence of the composition of the pressure fluctuation signals, energy of low frequency (ELF) is proposed to show the transition of fluidized regimes from bubbling fluidization to turbulent fluidization. Plots are presented to describe the fluidized bed's evolution to help identify the state of different flow regimes and provide a characteristic curve to identify the fluidized status effectively and reliably.展开更多
Double-suction centrifugal pumps have been applied extensively in many areas,and the significance of pressure fluctuations inside these pumps with large power is becoming increasingly important.In this study,a double-...Double-suction centrifugal pumps have been applied extensively in many areas,and the significance of pressure fluctuations inside these pumps with large power is becoming increasingly important.In this study,a double-suction centrifugal pump with a high-demand for vibration and noise was redesigned by increasing the flow uniformity at the impeller discharge,implemented by combinations of more than two parameters.First,increasing the number of the impeller blades was intended to enhance the bounding effect that the blades imposed on the fluid.Subsequently,increasing the radial gap between the impeller and volute was applied to reduce the rotor-stator interaction.Finally,the staggered arrangement was optimized to weaken the efficacy of the interference superposition.Based on numerical simulation,the steady and unsteady characteristics of the pump models were calculated.From the fluctuation analysis in the frequency domain,the dimensionless pressure fluctuation amplitude at the blade passing frequency and its harmonics,located on the monitoring points in the redesigned pumps(both with larger radial gap),are reduced a lot.Further,in the volute of the model with new impellers staggered at 12°,the average value for the dimensionless pressure fluctuation amplitude decreases to 6%of that in prototype pump.The dimensionless rootmean-square pressure contour on the mid-span of the impeller tends to be more uniform in the redesigned models(both with larger radial gap);similarly,the pressure contour on the mid-section of the volute presents good uniformity in these models,which in turn demonstrating a reduction in the pressure fluctuation intensity.The results reveal the mechanism of pressure fluctuation reduction in a double-suction centrifugal pump,and the results of this study could provide a reference for pressure fluctuation reduction and vibration performance reinforcement of doublesuction centrifugal pumps and other pumps.展开更多
In this study on the nature of pressure signals generated by a deterministic or stochastic process in a bubbling fluidized bed, pressure fluctuation measurements were carried out in a 300-mm-diamet column at 0.090 m...In this study on the nature of pressure signals generated by a deterministic or stochastic process in a bubbling fluidized bed, pressure fluctuation measurements were carried out in a 300-mm-diamet column at 0.090 m and 0.40 m above the distributor for different gas velocities. The method of detecting deterministic dynamic underlying pressure signals is proposed on the basis of predictability of pressure fluctuations. The deterministic nature of dynamics in fluidizing system was verified. The deterministic level of dynamics in fluidizing system was analyzed for different locations of pressure measurements and different gas velocities.展开更多
基金supported by the Pre-research Fund of Vibration and Noise Control Technology (No. 51334060101)
文摘The accuracy of fluctuating pressure test in wind tunnel is affected by the tube system. By employing contradistinctive experimental method, systematic study was conducted to investigate the effects of the tube system on fluctuating pressure. The analyzed tube system parameters include tube length, inside diameter, curvature, deflection angle, thickness, material, restrictor length,restrictor inside diameter, and restrictor place. It is found that all the tube system parameters mentioned above except tube curvature have non-negligible effects on fluctuating pressure. Based on the research results, test methods were presented for the fluctuating pressure measurement in low-speed wind tunnel, which can obviously improve the data accuracy but not lose test efficiency. The effectiveness of the method is verified by the wind tunnel test.
基金Acknowledgements The authors acknowledge the support from the Key National Natural Science Foundation of China （No. 91116009 ＆ No. 91216114）. The support provided by the FD-20 wind tunnel staff is greatly appreciated.
文摘An experimental study was conducted on the interactions of shock wave/turbulence or laminar boundary layer caused by fin-type protuberance, as the lack of detailed understanding of fluctuating pressure loads inside and outside the laminar or turbulence boundary layer separation region in hypersonic flow. The changes of fluctuating pressure in separation region were focused on in this paper. The study shows that the existence of fin changes flowfiled on the plate significantly. The laminar boundary layer separation occurs earlier and the separation region is more extensive. Similar flow is observed between a couple of measurement points outside the laminar separation region. However, there are significant differences between the flow inside and outside the separation region. The level of fluctuating pressure of laminar boundary layer is smaller than that in turbulent case. Even so, in laminar case, the peak fluctuating pressure still reaches a high level. Therefore, the structural influence （damage and/or early fatigue） of fluctuating pressure loads caused by the laminar boundary layer separation should not be ignored.
基金Project supported by the Key Research and Development Plan Project of China(Grant No.2022YFC3204602)the National Natural Science Foundation of China(Grant No.U21A20157).
文摘This study conducts a comparative analysis between detached eddy simulation(DES)and Unsteady Reynolds-averaged Navier-Stokes(URANS)models for simulating pressure fluctuations in a stilling basin,aiming to assess the URANS mode’s performance in modeling pressure fluctuation.The URANS model predicts accurately a smoother flow field and its time-average pressure,yet it underestimates the root mean square of pressure(RMSP)fluctuation,achieving approximately 70%of the results predicted by DES model on the bottom floor of the stilling basin.Compared with DES model’s results,which are in alignment with the Kolmogorov−5/3 law,the URANS model significantly overestimates low-frequency pulsations,particularly those below 0.1 Hz.We further propose a novel method for estimating the RMSP in the stilling basin using URANS model results,based on the establishment of a quantitative relationship between the RMSP,time-averaged pressure,and turbulent kinetic energy in the boundary layer.The proposed method closely aligns with DES results,showing a mere 15%error level.These findings offer vital insights for selecting appropriate turbulence models in hydraulic engineering and provide a valuable tool for engineers to estimate pressure fluctuation in stilling basins.
基金supported by the Open Fund of Science and Technology on Thermal Energy and Power Laboratory[TPL2021A02]the State Key Laboratory of Hydroscience and Engineering[sklhse-2023-E-01].
文摘Centrifugal pumps are extensively employed in ocean engineering,such as ship power systems,water transportation,and mineral exploitation.Pressure fluctuation suppression is essential for the operation stability and service life of the centrifugal pump.In this paper,a new method of bionic structure is proposed for the blade surface of a centrifugal pump,which is inspired by the fish scale and comprises a leading edge,a trailing edge,and two symmetrical side edges.This fish scale structure is applied to the blade pressure and suction surfaces,and an impeller with a fish scale structure is constructed.A test rig for a centrifugal pump is developed to determine the pressure fluctuation in the pump with a prototype impeller and fish scale structure impeller.Results reveal that the dominant frequency of pressure fluctuation in volute is the blade passing frequency(f_(bpf))of 193.33 Hz,which is triggered by the interaction between the tongue and the impeller.The bionic structure of the fish scale effectively suppresses the pressure fluctuation amplitude at f_(bpf).From flow rates of 0.6 Q_(d)to 1.2 Q_(d),the average suppressions in pressure fluctuation amplitudes at f_(bpf)are 20.98%,5.85%,19.20%,and 25.77%.
文摘Using four types of stilling basin models,this paper studies frequency characteris- tics of the fluctuating pressure acting on the stilling basin apron when Froude number is not greater than 4.5.The testing results show that the frequency of fluctuating pressure,f_s in the ranges of 0. 4Hz≤f_s≤1.1Hz.0.2Hz≤f_s≤2.5Hz and 0.4Hz≤f_s≤3.3Hz.can be used as the design frequency corresponding to three patterns of hydraulic jump.The reliability of f_s for three jump patterns is all nearly equal to 90%.
基金Project supported by the National Natural Science Foundation of China(No.11402088)the Fundamental Research Funds for the Central Universities(No.2014MS33)the State Key Laboratory of Alternate Electrical Power System with Renewable Energy Sources(No.LAPS15005)
文摘A new view of the spatial relation between fluctuating wall pressure and near-wall streamwise vortices （NWSV） is proposed for wall bounded turbulent flow by use of the direct numerical simulation （DNS） database. The results show that the wall region with low pressure forms just below the strong NWSV, which is mostly associated with the overhead NWSV. The wall region with high pressure forms downstream of the NWSV, which has a good correspondence with the downwash of the fluids induced by the upstream NWSV. The results provide a significant basis for the detection of NWSV.
基金co-supported by the National Natural Science Foundation of China(Nos.12232018 and 11972356)the National Key Research and Development Program of China(No.2019YFA0405200)。
文摘This study investigates high-amplitude Extreme Wall Pressure fluctuation Events(EWPEs)in Shock wave/Turbulent Boundary Layer Interactions(STBLIs)through the conditional sampling of direct numerical simulation databases.The aim is to evaluate the effect of STBLIs and their strength on the statistical properties and associated turbulent structures of EWPEs using the conditional-averaging and clustering method.The temporal statistical results show that the occurrence probability and contribution ratio of EWPEs decrease downstream of strong STBLI,but their duration and interval time increase.Regarding two-dimensional wall pressure structures,the large population of small-scale structures becomes more elongated,but strong interactions induce a greater number of large-scale structures.The pairing of wall pressure events with a higher occurrence probability is verified by the joint probability density functions.Conditional analysis reveals that,as the interaction strength increases,the ejection motion associated with positive events occurs farther downstream and the spanwise vortex core locating above negative events is lifted up along the wall-normal direction.Moreover,analysis associates the paired wall pressure events with the sweep,ejection,and swirl motions in STBLIs,where hairpin eddies play an important role in the formation of positive-negative paired wall pressure structures.
基金supported by the National Natural Science Foundation of China(Nos.12172354,12388101,U21B6003)the Strategic Priority Research Program of Chinese Academy of Sciences(No.XDB0620201).
文摘Open cavities with different door-opening angles are investigated using high-speed schlieren visualization and dynamic pressure measurements in hypersonic flow with a freestream Mach number of 6.With the help of numerical simulations,the shear layer deformation and pressure increase in the cavities due to the impingement of the door-leading-edge shocks are identified via comparison with those in the cavity without doors.As the door-opening angle decreases from 90°,the shear layer above the forepart of the cavity is gradually raised by the high pressure in the cavity.When the door-opening angle decreases to 30°and 15°,the boundary layer on the upstream flat plate of the cavity separates,and separation shock is observed.The doors enhance the instability of the cavity flow and increase the pressure fluctuations in the cavities.A new oscillation pattern,referred to as coupled oscillation,is observed in the cases with separation on the upstream flat plate,in which the separation shock oscillates at the same dominant frequency as the flow inside the cavity.Compared with the cavity without doors,this coupled oscillation causes a lower oscillation frequency and a larger overall sound pressure level.Cross-correlation analyses between pressure signals indicate that the disturbances generated at the trailing edge of the cavity can propagate to the separation on the upstream flat plate and cause coupled oscillation of the separation shock.The fundamental frequencies of the coupled oscillations can be normalized to approximately the same Strouhal number as that of the cavity without doors.These findings support that the oscillation mechanisms of hypersonic cavities without and with doors are primarily dominated by acoustic feedback.
基金supported by National Outstanding Young Scientists Funds of China (Grand No.50825902)
文摘The pressure fluctuation in the flow passage of both impeller and casing is addressed on design condition. The initial conditions for the unsteady turbulent simulation are resulted from the steady calculations, and the three dimensional unsteady turbulent simulation concerning the rotor-stator interaction is executed by a Navier-Stoke solver embedded with k -ε turbulence model and with appropriate moving interface boundary conditions. Detecting points are distributed in the flow passage in different radial and circumferential positions to capture the static pressure fluctuation character for one cycle of the impeller. The time-domain spectrums show that the static pressure curves are periodic and have five peaks and five valleys. With the radius increasing, the pressure fluctuation peak-to-peak values in the impeller are increasing, and reach the maximum value on the interface. In the casing flow passage, those values are about 7% of local static pressure except some ones near the tongue. The values become decreasingly in the diffuser pipe. The frequency spectrums transformed by fast Fourier transform （FFT） show that the dominant frequency is approximate with the blade passing frequency, and the pressure fluctuations in impeller passage have high frequency content while those in casing ones have no such information.
基金supported by National Natural Science Foundation of China(Grant No. 50976061)State Key Laboratory of Hydroscience and Engineering of China(Grant No. 2010-ZY-4)Beijing Municipal Natural Science Foundation of China(Grant No. 3072008)
文摘Frequent shifts of output and operating mode require a pump turbine with excellent stability. Current researches show that large partial flow conditions in pump mode experience positive-slope phenomena with a large head drop. The pressure fluctuation at the positive slope is crucial to the pump turbine unit safety. The operating instabilities at large partial flow conditions for a pump turbine are analyzed. The hydraulic performance of a model pump turbine is tested with the pressure fluctuations measured at unstable operating points near a positive slope in the performance curve. The hydraulic performance tests show that there are two separated positive-slope regions for the pump turbine, with the flow discharge for the first positive slope from 0.85 to 0.91 times that at the maximum efficiency point. The amplitudes of the pressure fluctuations at these unstable large partial flow conditions near the first positive slope are much larger than those at stable operating condtions. A dominant frequency is measured at 0.2 times the impeller rotational frequency in the flow passage near the impeller exit, which is believed to be induced by the rotating stall in the flow passage of the wicket gates. The test results also show hysteresis with pressure fluctuations when the pump turbine is operated near the first positive slope. The hysteresis creates different pressure fluctuations for those operation points even though their flow rates and heads are similar respectively. The pressure fluctuation characteristics at large partial flow conditions obtained by the present study will be helpful for the safe operation of pumped storage units.
基金Supported by the National High Technology Research and Development Program of China(2006AA09Z302)
文摘During the exploitation of offshore oil and gas,it is easy to form severe slugging which can cause great harm in the riser connecting wellheads and offshore platform preprocessing system.The flow pattern and pressure fluctuation of severe slugging were studied in an experimental simulation system with inner diameter of 0.051 m.It is found that severe slugging can be divided into three severe slugging regimes：regime I at low gas and liquid flow rates with large pressure fluctuation,intermittent flow of liquid and gas in the riser,and apparent cutoff of liquid phase,regime II at high gas flow rate with non-periodic fluctuation and discontinuous liquid outflow and no gas cutoff,regime III at high liquid flow rate with degenerative pressure fluctuation in form of relatively stable bubbly or plug flow.The results indicate that severe slugging still occurs when the declination angle of pipeline is 0,and there are mainly two kinds of regimes：regime I and regime II.As the angle increases,the formation ranges of regime I and regime III increase slightly while that of regime II is not affected.With the increase of gas superficial velocity and liquid superficial velocity,the pressure fluctuation at the bottom of riser increases initially and then decreases.The maximum value of pressure fluctuation occurs at the transition boundary of regimes I and II.
基金Project supported by the Priority Academic Development Program of Jiangsu Higher Education Institutions, ChinaProject(CXZZ12_0680) supported by Postgraduate Innovation Foundation of Jiangsu Province, ChinaProject(12JDG082) supported by the Advanced Talent Foundation of Jiangsu University, China
文摘In order to investigate the effect of sampling frequency and time on pressure fluctuations, the three-dimensional unsteady numerical simulations were conducted in a circulating water pump. Through comparison of turbulence models with hydraulic performance experiment, SST k-co model was confirmed to study the rational determination of sampling frequency and time better. The Fast Fourier Transform （FFT） technology was then adopted to process those fluctuating pressure signals obtained. On these bases, the characteristics of pressure fluctuations acting on the tongue were discussed. It is found that aliasing errors decrease at higher sampling frequency of 17 640 Hz, but not at a lower sampling frequency of 1 764 Hz. Correspondingly, an output frequency range ten-times wider is obtained at 17 640 Hz. Compared with 8R, when the sampling time is shorter, the amplitudes may be overvalued, and the frequencies and amplitudes of low-frequency fluctuations can not be well predicted. The frequencies at the tongue are in good agreement with the values calculated by formula and the frequency compositions less than the blade passing frequency are accurately predicted.
基金the National Natural Science Foundation of China （No.29276260, No.20176043）.ACKN0WLEDGEMENT The authors would like to thank Dr. Zhang Jian- wei who worked a lot in preparation of the apparatus for pressure fluctuation measurements.
文摘Pressure fluctuation in the submerged circulative impinging stream reactor （SCISR） is studied by measuring the dynamic pressure with micro pressure sensors of high accuracy, with water as the process material. Experimental results show that the maximum amplitude of fluctuation can be up to about 1.6kPa. On the power spectra the fluctuation is relatively concentrated in the range of 〈1000Hz, with some weak peeks in acoustic wave range. The space profile of intensive fluctuation region in the reactor is determined. The region is found to take the form of a couple truncated cones of empty core, with coincided bottoms, and is symmetrical with respect to the impinging plane and approximately symmetrical about the axis, essentially independent of u0. The integral intensity of fluctuation increases as the impinging velocity, Uo increasing.
基金supported by National Natural Science Foundation of China(Grant Nos. 51079152, 91010003, 51079151)Research Fund for the Doctoral Program of Higher Education of China(Grant No.0100008110012)Beijing Municipal Research Fund of Commission of Education of China(Grant No. 20100909)
文摘The pressure fluctuation caused by unsteady flow in runner is one of the main reasons of vibration for a large Francis hydraulic turbine. It directly affects the steady operation of the hydraulic turbine unit. The existing research of the pressure fluctuation in hydraulic turbine mainly focuses on the unsteady flow in draft tube. Accurate distribution of pressure fluctuations inside a runner is not very clear. In this paper, the numerical method for predicting the pressure fluctuations in runner is investigated and the numerical simulation is performed for a large Francis hydraulic turbine. It is proved that the combination of shear-stress transport（SST） k-o） turbulence model and pressure-implicit with splitting of operators（PISO） algorithm could give more reliable prediction of pressure fluctuations in runner. The frequencies of pressure fluctuations in runner are affected by the flow in guide vane and the flow in draft tube The first dominant frequency is significantly determined by the flow in draft tube, especially at part load condition. This frequency is approximately equal to one-third of the runner rotating frequency. The evident second dominant frequency is exactly equal to the guide vane passing frequency. The peak-to-peak amplitudes of pressure fluctuations in runner at small guide vane open angle are larger than that at large open angle at the same operating head. The amplitudes at points on blade pressure surface are generally greater than that on suction surface. The research results could be used to direct the hydraulic design and operation stability improvement of a large Francis hydraulic turbine.
基金Supported by National Natural Science Foundation of China (Grant Nos.51621061,51139007,51409247)National Science and Technology Support Project of China(Grant No.2015BAD20B01)
文摘Pressure fluctuation may cause high amplitude of vibration of double-suction centrifugal pumps, but the impact of impeller stagger angles is still not well understood. In this paper, pressure fluctuation experiments are carried out for five impeller configurations with different stagger angles by using the same test rig system. Results show that the stagger angles exert negligible effects on the characteristics of head and efficiency. The distributions of pressure fluctuations are relatively uniform along the suction chamber wall, and the maximum pressure fluctuation amplitude is reached near the suction inlet tongue region. The pressure fluctuation characteristics are affected largely by impeller rotation, whose dominant frequencies include impeller rotation frequency and its harmonic frequencies, and half blade passage frequency. The stagger angle exerts a small effect on the pressure fluctuations in the suction chamber while a great effect on the pressure fluctuation in volute casing, especially on the aspect of decreasing the amplitude on blade passage frequency. Among the tested cases, the distribution of pressure fluctuations in the volute becomes more uniform than the other impeller configurations and the level of pressure fluctuation may be reduced by up to 50% when the impeller stagger angle is close to 24° or 360°.The impeller structure pattern needs to be taken into consideration during the design period, and the halfway staggered impeller is strongly recommended.
基金Project (No. 50809013) supported by the National Natural Science Foundation of China
文摘This study established a 3D finite element model for 15# hydropower house of the Three Gorges Project (TGP) and performed a nonlinear dynamic analysis under pressure fluctuation. In this numerical model, the stiffness degradation in tension for concrete was considered on the basis of the continuum isotropic damage theory. Natural vibration frequencies of the damaged and undamaged structures were compared after static water pressure was applied. Then a study was further conducted on forced vibration of the powerhouse with pre-existing damages under pressure fluctuation that acts on the flow passage; displacement, velocity and acceleration of the important structural members were afterwards presented and checked. Numerical results show that tensile damages in concrete surrounding the spiral case only exert significant impact upon the dynamic characteristics of substructure but show little effect on the superstructure. Nevertheless vibrations of the powerhouse are still under the recommended vibration limits.
文摘Calculation grid and turbulence model for numerical simulating pressure fluctuations in a high-speed train tunnel are studied through the comparison analysis of numerical simulation and moving model test.Compared the waveforms and peak-peak values of pressure fluctuations between numerical simulation and moving model test,the structured grid and the SST k-ωturbulence model are selected for numerical simulating the process of high-speed train passing through the tunnel.The largest value of pressure wave amplitudes of numerical simulation and moving model test meet each other.And the locations of the largest value of the initial compression and expansion wave amplitude of numerical simulation are in agreement with that of moving model test.The calculated pressure at the measurement point fully conforms to the propagation law of compression and expansion waves in the tunnel.
文摘It has been shown that much dynamic information is hidden in the pressure fluctuation signals of a gas-solid fluidized bed. Unfortunately, due to the random and capricious nature of this signal, it is hard to realize reliable analysis using traditional signal processing methods such as statistical analysis or spectral analysis, which is done in Fourier domain. Information in different frequency band can be extracted by using wavelet analysis. On the evidence of the composition of the pressure fluctuation signals, energy of low frequency (ELF) is proposed to show the transition of fluidized regimes from bubbling fluidization to turbulent fluidization. Plots are presented to describe the fluidized bed's evolution to help identify the state of different flow regimes and provide a characteristic curve to identify the fluidized status effectively and reliably.
基金Supported by National Natural Science Foundation of China(Grant Nos.52076186,51839010).
文摘Double-suction centrifugal pumps have been applied extensively in many areas,and the significance of pressure fluctuations inside these pumps with large power is becoming increasingly important.In this study,a double-suction centrifugal pump with a high-demand for vibration and noise was redesigned by increasing the flow uniformity at the impeller discharge,implemented by combinations of more than two parameters.First,increasing the number of the impeller blades was intended to enhance the bounding effect that the blades imposed on the fluid.Subsequently,increasing the radial gap between the impeller and volute was applied to reduce the rotor-stator interaction.Finally,the staggered arrangement was optimized to weaken the efficacy of the interference superposition.Based on numerical simulation,the steady and unsteady characteristics of the pump models were calculated.From the fluctuation analysis in the frequency domain,the dimensionless pressure fluctuation amplitude at the blade passing frequency and its harmonics,located on the monitoring points in the redesigned pumps(both with larger radial gap),are reduced a lot.Further,in the volute of the model with new impellers staggered at 12°,the average value for the dimensionless pressure fluctuation amplitude decreases to 6%of that in prototype pump.The dimensionless rootmean-square pressure contour on the mid-span of the impeller tends to be more uniform in the redesigned models(both with larger radial gap);similarly,the pressure contour on the mid-section of the volute presents good uniformity in these models,which in turn demonstrating a reduction in the pressure fluctuation intensity.The results reveal the mechanism of pressure fluctuation reduction in a double-suction centrifugal pump,and the results of this study could provide a reference for pressure fluctuation reduction and vibration performance reinforcement of doublesuction centrifugal pumps and other pumps.
文摘In this study on the nature of pressure signals generated by a deterministic or stochastic process in a bubbling fluidized bed, pressure fluctuation measurements were carried out in a 300-mm-diamet column at 0.090 m and 0.40 m above the distributor for different gas velocities. The method of detecting deterministic dynamic underlying pressure signals is proposed on the basis of predictability of pressure fluctuations. The deterministic nature of dynamics in fluidizing system was verified. The deterministic level of dynamics in fluidizing system was analyzed for different locations of pressure measurements and different gas velocities.
