Anaerobic digestion(AD)is widely employed for sludge stabilization and waste reduction.However,the slow hydrolysis process hinders methane production and leads to prolonged sludge issues.In this study,an efficient and...Anaerobic digestion(AD)is widely employed for sludge stabilization and waste reduction.However,the slow hydrolysis process hinders methane production and leads to prolonged sludge issues.In this study,an efficient and eco-friendly lysozyme pre-treatment method was utilized to address these challenges.By optimizing lysozyme dosage,hydrolysis and cell lysis were maximized.Furthermore,lysozyme combined with hydrothermal pretreatment enhanced overall efficiency.Results indicate that:(1)When lysozyme dosage reached 90 mg/g TS after 240 min of pretreatment,SCOD,soluble polysaccharides,and protein content reached their maxima at 855.00,44.09,and 204.86 mg/L,respectively.This represented an increase of 85.87%,365.58%,and 259.21%compared to the untreated sludge.Threedimensional fluorescence spectroscopy revealed the highest fluorescence intensity in the IV region(soluble microbial product),promoting microbial metabolic activity.(2)Lysozyme combined with hydrothermal pretreatment significantly increased SCOD,soluble proteins,and polysaccharide release from sludge,reducing SCOD release time.Orthogonal experiments identified Group 3 as the most effective for SCOD and soluble polysaccharide release,while Group 9 released the most soluble proteins.The significance order of factors influencing SCOD,soluble proteins,and polysaccharide release is hydrothermal temperature>hydrothermal time>enzymatic digestion time.(3)The lysozyme-assisted hydrothermal pretreatment group exhibited the fastest release and the highest SCOD concentration of 8,135.00 mg/L during anaerobic digestion.Maximum SCOD consumption and cumulative gas production increased by 95.89%and 130.58%,respectively,compared to the control group,allowing gas production to conclude 3 days earlier.展开更多
The innovative process consists of biological unit for wastewater treatment and ozonation unit for excess sludge treatment. An aerobic membrane bioreactor(MBR) was used to remove organics and nitrogen, and an anaerobi...The innovative process consists of biological unit for wastewater treatment and ozonation unit for excess sludge treatment. An aerobic membrane bioreactor(MBR) was used to remove organics and nitrogen, and an anaerobic reactor was added to the biological unit for the release of phosphorus contained at aerobic sludge to enhance the removal of phosphorus. For the excess sludge produced in the MBR, which was fed to ozone contact column and reacted with ozone, then the ozonated sludge was returned to the MBR for further biological treatment. Experimental results showed that this process could remove organics, nitrogen and phosphorus efficiently, and the removals for COD, NH 3-N, TN and TP were 93.17%, 97.57%, 82.77% and 79.5%, respectively. Batch test indicated that the specific nitrification rate and specific denitrification rate of the MBR were 1.03 mg NH 3-N/(gMLSS·h) and 0.56 mg NOx-N/(gMLSS·h), and denitrification seems to be the rate-limiting step. Under the test conditions, the sludge concentration in the MBR was kept at 5000—6000 mg/L, and the wasted sludge was ozonated at an ozone dosage of 0.10 kgO 3/kgSS. During the experimental period of two months, no excess sludge was wasted, and a zero withdrawal of excess sludge was implemented. Through economic analysis, it was found that an additional ozonation operating cost for treatment of both wastewater and excess sludge was only 0.045 RMB Yuan(USD 0.0054)/m 3 wastewater.展开更多
The releasing characteristics of phosphorus, nitrogen compounds, organics, and some metal cations during thermal treatment of excess sludge were investigated. It was found that during heating not only phosphorus, but ...The releasing characteristics of phosphorus, nitrogen compounds, organics, and some metal cations during thermal treatment of excess sludge were investigated. It was found that during heating not only phosphorus, but also nitrogen compounds, organics, and some metal cations could be released in abundance. The maximum orthophosphate （ortho-P） release of about 90 mg/L in concentration was observed at 50℃ in 1 h. Except for volatile fatty acids （VFAs）, comparatively little total nitrogen （TN）, total organic carbon （TOC）, and metal cations were released at the same time. Such results might favor further process of phosphorus recovery. VFAs were considerably released only at 50℃. Acetic, butyric, and propionic acid were the most abundant components in turn and their releasing profiles exhibited good linear relationship with time （R2 = 0.9977, 0.9624, and 0.8908, respectively）. The concentrations of Mg^2＋ and K^＋ increased with time and temperature during thermal treatment, but Ca^2＋ decreased. The release of Mg^2＋ and K^＋ agreed well with TP release （R^2 = 0.9892 and 0.9476, respectively）. Temperature in the experimental range had very little impact on the linear relationships, especially of Mg^2＋. Moreover, the parameter of mixed liquor suspended solids （MLSS） was found to be an important factor for thermal sludge treatment as the released ortho-P and total phosphorus （TP） at 50℃ increased more than one-fold when MLSS was increased from 4000 to 8000 mg/L.展开更多
Domestic wastewater was treated by combined anaerobic biofilm aerobic membrane bioreactor(MBR) process, and part biomass in MBR was withdrawn to treat with ozone, then the ozonated sludge was returned to anaerobic in...Domestic wastewater was treated by combined anaerobic biofilm aerobic membrane bioreactor(MBR) process, and part biomass in MBR was withdrawn to treat with ozone, then the ozonated sludge was returned to anaerobic inlet. In aerobic MBR, MLSS and DO were controlled at 3000—3500 mg/L and 0 8 mg/L respectively. Comparing the experimental results of two stages, it was noticed that ozonation did not affect the removal efficiency for organics but had a significant influence on the removals of NH 3 N and TN. During the ozonation period of two months, no excess sludge was wasted, and a zero sludge yield was obtained.展开更多
In order to enhance the efficiency of aerobic digestion, the excess sludge was irradiated by low intensity ultrasound at a frequency of 28 kHz and acoustic intensity of 0.53 W/cm^2. The results show that the sludge st...In order to enhance the efficiency of aerobic digestion, the excess sludge was irradiated by low intensity ultrasound at a frequency of 28 kHz and acoustic intensity of 0.53 W/cm^2. The results show that the sludge stabilization without ultrasonic treatment can be achieved after 17 d of digestion, whereas the digestion time of ultrasonic groups can be cut by 3-7 d. During the same digestion elapsing, in ultrasonic groups the total volatile suspended solid removal rate is higher than that in the control group. The kinetics of aerobic digestion of excess sludge with ultrasound can also be described with first-order reaction.展开更多
Recently,more and more attention has been paid to the strong oxidation ability of newly prepared potassium ferrate(NAPF) in sludge reduction process,but less attention has been paid to the change of phosphorus in this...Recently,more and more attention has been paid to the strong oxidation ability of newly prepared potassium ferrate(NAPF) in sludge reduction process,but less attention has been paid to the change of phosphorus in this process.The feasibility of phosphorus migration and transformation during excess sludge reduction pretre atment using NAPF pre-oxidation combined with anaerobic digestion was investigated.After 70 mg/g suspended solids NAPF pretreatment and 16 days anaerobic digestion,the solid-phase volatile suspended solids decreased by 44.2%,and much organic matter had been released into the liquid-phase and then degraded during digestion by indigenous microorganisms.As the sludge pre-oxidation process was performed,solid-phase organic phosphorus and chemically combined phosphorus also released into the liquid-phase as PO4^3-,peaking at 100 mg/L.During anaerobic digestion,the Fe3+in the liquid-phase was gradually reduced to Fe2+,and then formed Fe^2+-PO4^3- compound crystals and re-migrated to the solid-phase.The concentration of PO4^3- decreased to 17.08± 1.1 mg/L in the liquid-phase after anaerobic digestion.Finally,the phosphorus in the Fe^2+-PO4^3- compound accounts for 80% of the total phosphorus in the solid-phase.A large number of vivianite crystals in sludge were observed.Therefore,this technology not only effectively reduces sludge,but also increases the proportion of PO43-in the sludge in the form of Vivianite.展开更多
A group of Zn-Al layered double hydroxides (LDHs) were synthesized at different temperatures from 25-90 °C in order to investigate the influence of synthesis temperature on characteristics of the LDHs and their p...A group of Zn-Al layered double hydroxides (LDHs) were synthesized at different temperatures from 25-90 °C in order to investigate the influence of synthesis temperature on characteristics of the LDHs and their phosphate adsorption behaviour. The results reveal that an increase in the synthesis temperature generally improves the specific surface area of the sample and the phosphate adsorption capacity. The significantly enhanced crystallin- ity of the Zn-Al-30, synthesized at 30 °C, leads to a remarkable decrease in the specific surface area and consequently a poor phosphate adsorption capacity. It is suggested that the surface adsorption plays an important role in the phosphate uptake by the Zn-Al LDHs. Zn-Al-70 presents a relatively higher crystallinity and a lower specific surface area, compared with Zn-Al-60 and Zn-Al-80, but the highest phosphate adsorption capacity, indicating that surface adsorption is only one of the pathways for phosphate removal. The phosphate adsorption by the Zn-Al follows a pseudo-second-order kinetic equation. The adsorption isotherms fit Langmuir models, and the maximum a dsorption capacities of the Zn-Al-25, Zn-Al-50 and Zn-Al-70 are estimated to be 17.82, 21.01 and 27.10 mg·g-1 adsorbent, respectively.展开更多
To seek for an alternative solution for the treatment and disposal of excess activated sludge,a hybrid system of membrane bioreactor(MBR)coupled with ozonation process(i.e.,ozonation run)was set up to treat the domest...To seek for an alternative solution for the treatment and disposal of excess activated sludge,a hybrid system of membrane bioreactor(MBR)coupled with ozonation process(i.e.,ozonation run)was set up to treat the domestic wastewater.A reference run without ozonation was also preformed as a control.The optimal ozone dose of 0.16mg O3·mg MLVSS-1 used for the sludge solubilization in the ozonation run was firstly determined through the batch sludge ozonation tests.A 40-day continuous operation of the two parallel systems demonstrated that circulation of ozonized sludge as lysate did not impact the performance of MBR in terms of organic and ammonia removal.On the contrary,an improvement in TN removal(by 7.7%)and sludge reduction(by 54%)was observed in the ozonation-combined MBR,and it was furthermore illustrated by the calculation of the mass balance based on the COD and TN substances.In addition,ozonation did not deteriorate the sludge activities for the ozonation run,indicating that not much inert organic materials built up in the bioreactor.Decreased VSS/SS ratio and lower amount of filamentous bacteria after ozonation treatment on the other hand improved the sludge settleability,as lower and constant Sluge Volume Index(SVI)values were detected in the ozonation run.展开更多
In order to study the effect of excess sludge ozonation, a continuous experiment in lab scale process was carried out. During the treatment process, a high level of ozone was produced by the electrolysis-type ozone ge...In order to study the effect of excess sludge ozonation, a continuous experiment in lab scale process was carried out. During the treatment process, a high level of ozone was produced by the electrolysis-type ozone generator, and various parameters, such as Soluble Chemical Oxygen Demand （SCOD）, Mixed Liquor Suspended Solids （MLSS）, Mixed Liquor Volatile Suspended Solids （MLVSS）, pH and so on, which char- acterize sludge were investigated. A substantial reduction in the volume of sludge and the release of intracellular materials were observed： SCOD proliferated as a consequence of extending the ozone feeding time; MLSS and MLVSS, especially the ratio of MLVSS to MLSS, dwindled as the action time rose. Through analyzing the effluent quality and excess sludge activity, the sludge-water volume mixture ratio of 1 ： 20 with 50 -60 minutes＇ oxidation treatment was found to be the optimal condition for ozonic disintegration of excess sludge. A remarkable sludge reduction rate of 57% could be achieved under the ozone feeding time of 40 minutes, which revealed the optimal action time.展开更多
In order to investigate the influence factors of zero excess activated sludge (EAS) process by ozonation, a 100 L membrane bioreactor coupled with a sludge ozonation unit (MBR-SO) was performed for 80 d without EAS wa...In order to investigate the influence factors of zero excess activated sludge (EAS) process by ozonation, a 100 L membrane bioreactor coupled with a sludge ozonation unit (MBR-SO) was performed for 80 d without EAS wasting. Some mathematical models were developed to elucidate the relationship between process parameters and the operating effects. It is considered that the sludge lysing ratio (ξ), produced COD per unit mass lysed MLSS (η), observed sludge yield coefficient (Yobs) and intrinsic yield coefficient for COD produced by lysed sludge (Y2) significantly affect the flowrate to ozonation unit (q). When q is 0.0067 times of influent flowrate (Q) and ξ is about 0.72 for each batch ozonation, a relatively stable MLSS concentration of 8168 mg/L and zero Yobs are achieved in the MBR-SO system. The calculation of sludge disintegration number indicates that the high ξ can apparently decrease the sludge amount needed for ozonation. At the same ozone dose, the low input ozone concentration and high flowrate can enhance the sludge lysing effects and a low energy consumption of 0.041 Yuan/m3 wastewater is obtained.展开更多
Anaerobic fermentation is an efficient method to extract phosphorus from excess sludge,thereby facilitating its recovery and mitigating the phosphorus resource shortage.However,the prevalent metal-bound phosphorus spe...Anaerobic fermentation is an efficient method to extract phosphorus from excess sludge,thereby facilitating its recovery and mitigating the phosphorus resource shortage.However,the prevalent metal-bound phosphorus species within sludge was difficult to release into the fermentation liquor.To address this,this study evaluated the enhanced phosphorus release performance from sludge containing iron-phosphorus compounds(Fe-P)via co-fermenting it with agriculture wastes.Specifically,protein-rich feather(Feather Group)and polysaccharide-rich tea residue(Tea Group)was respectively dosed into batch-scale fermentation jar.Results showed that the Feather Group exhibited significantly higher levels of released soluble phosphorus(2.1 folds)and volatile fatty acids(41.4 folds)compared to the Control Group,with concentrations reaching up to 280 mg/L and 9366 mg chemical oxygen demand/L,respectively.The activities ofα-glucosidase,neutral protease and acetate kinase in the Feather group were increased by 11.1%,92.3%and 37.6%,respectively,compared with the Control group.Methanogen abundance decreased while hydrolytic acid-producing bacteria and iron-reducing bacteria increased significantly after supplying agricultural wastes.Metagenomic analysis demonstrated a significant increase in genes related to acetic acid synthesis.Mechanism elucidation suggested that increased iron-reducing bacteria abundance promoted Fe3+reduction into Fe2+,thus enhancing phosphorus release from Fe-P compounds.This work may provide valuable information for developing effective strategy to extract phosphorus resource from complex environmental wastes.展开更多
In order to study the minimization of excess sludge production,the reduction in the excess sludge production in the presence of an inhibitor and uncoupler was studied in this work.The experimental results show that su...In order to study the minimization of excess sludge production,the reduction in the excess sludge production in the presence of an inhibitor and uncoupler was studied in this work.The experimental results show that such an addition could effectively reduce the production of excess sludge.With the energy uncoupling model established in this work,energy uncoupling coefficient(Eu)was used to evaluate the reduction in excess sludge production.The energy uncoupling coefficients in the presence of dinitrophenol(dNP),Zn^(2+),and Cu^(2+)was 0.75,0.46,and 0.18,respectively.The analysis demonstrated that energy spilling occurred in the presence of dNP,and that dNP was an effective uncoupler for reducing the production of excess activated sludge without affecting the microbial respiration activity.展开更多
Thermal alkaline hydrolysis is a common pretreatment method for the utilization of excess activated sludge(EAS).Owing to strict environment laws and need for better energy utilization,new methods were developed in thi...Thermal alkaline hydrolysis is a common pretreatment method for the utilization of excess activated sludge(EAS).Owing to strict environment laws and need for better energy utilization,new methods were developed in this study to improve the efficiency of pretreatment method.Direct thermal hydrolysis(TH),pasteurized thermal hydrolysis(PTH),and alkaline pasteurized thermal hydrolysis(PTH+CaO and PTH+NaOH)methods were used to treat EAS.Each method was compared and analyzed in terms of dissolution in ammonium nitrogen(NH_(4)^(+)-N)and soluble COD(SCOD)in EAS.Furthermore,the removal of tetracycline resistance genes(TRGs)and class 1 transposon gene intI1 from EAS was investigated.The NH_(4)^(+)-N and SCOD concentrations in EAS treated by PTH were 1.24 and 2.58 times higher than those of TH.However,the removal efficiency of total TRGs and intI1 between the groups was comparable.The SCOD concentration of the PTH+NaOH group was 4.37 times higher than that of the PTH group,and the removal efficiency of total TRGs was increased by 9.52%compared with that by PTH.The NH_(4)^(+)-N and SCOD concentrations of the PTH+CaO group could reach 85.04%and 92.14%of the PTH+NaOH group,but the removal efficiency of total TRGs by PTH+CaO was 19.78%lower than that by PTH+NaOH.Thus,to reduce the financial cost in actual operation,lime(CaO)can be used instead of a strong alkali(NaOH),and pasteurized steam at 70℃ instead of conventional high-temperature heating to treat EAS.This study provides a reference for the development of alkaline hydrolysis under moderate temperatures along with the removal of TRGs in EAS.展开更多
A study was undertaken to investigate the production of amino acids from excess activated sludge (EAS) by enzymatic hydrolysis. Firstly, the protein was extracted from EAS. Secondly, the protein solution was further h...A study was undertaken to investigate the production of amino acids from excess activated sludge (EAS) by enzymatic hydrolysis. Firstly, the protein was extracted from EAS. Secondly, the protein solution was further hydrolyzed under free enzyme or immobilized enzyme. The reversed phase high performance liquid chromatography (RP-HPLC) and inductively coupled plasma emission spectrometer (ICP) were applied to determine the contents of amino acids and heavy metals, respectively. The effects of enzyme/substrate(E/S), pH, temperature, and reaction time were investigated in detail. The results indicated that, the optimum conditions for protein hydrolysis were temperature 55℃, pH 10, E/S 9 g/L, and reaction time 8 h, and the highest yield of amino acids was more than 10 g/100 g dry sludge (DS) under free enzyme. Moreover, the security and nutrition were taken into consideration. There were seven kinds of essential amino acids and ten non-essential amino acids in the raw amino acid (RAA) solution, and the contents of heavy metals were lower, living up to Hygienical standard for feeds (China). This technology widens the source of amino acids and makes the extraction of amino acids from EAS more economic and effective.展开更多
Sludge concentration subarea(A area and B area) is realized by mesh filter unit,solving the higher sludge concentration process problem of MBR system under zero excess sludge discharge conditions.Mass balance of the s...Sludge concentration subarea(A area and B area) is realized by mesh filter unit,solving the higher sludge concentration process problem of MBR system under zero excess sludge discharge conditions.Mass balance of the system is processed,and variety disciplinarians of VSS of A area and B area are analyzed.The results show that XA decreases while HRTA increases.XB decreases while R increases,and ascends as VSS(XA,B) of mesh effluent increases.When XB is a fixed value,XA,B increases as R does and XA decreases slowly while R increases,which theoretically proves the feasibility of the technique.展开更多
To investigate the effects of ozonation on minimizing the excess sludge and enhancing the nitrogen removal in an effluent, batch and continuous experiments in two MBRs with and without sludge ozonation （ namely combi...To investigate the effects of ozonation on minimizing the excess sludge and enhancing the nitrogen removal in an effluent, batch and continuous experiments in two MBRs with and without sludge ozonation （ namely combined and reference run） were carried out. Through ozonation at a dose of 0. 16 mg O3/mg MLVSS, 53.1% of the treated MLVSS was solubilized, and soluble SCOD/TN ratio of ozonized sludge （OS） was about 8. 6 due to the release of cellular nitrogen-contained materials and SCOD loss by ozone mineralization. In addition, the results of batch nitrification and denitrification tests with OS supernatant indicated that solubilized sludge could act as a reducing power for denitrification and a nitrogen source for nitrification. 40-day operation of-two MBR systems demonstrated that the recirculation of OS into a bioreaetor enabled the combined system have two advantages over the control one. The observed sludge yield （Yobs） was decreased from 0. 13 to 0. 06g MLSS/g COD, while the nitrogen removal was increased from 64. 6% to 72. 3%. And sludge ozonation elevated the inorganic fraction of MLSS, but did not impact sludge activities.展开更多
Based on the hypothesis of reducing sludge production under cryptic growth conditions, ozone was used as cell lysis agent to treat excess sludge,and then the ozonated supernatant was returned to the aeration tank. The...Based on the hypothesis of reducing sludge production under cryptic growth conditions, ozone was used as cell lysis agent to treat excess sludge,and then the ozonated supernatant was returned to the aeration tank. The results show that COD and NH+4-N removal efficiencies in ozonation process were 87.96% and 84.42%, respectively. Meanwhile, a low excess sludge yield coefficient of 0. 113 ( g SS/g COD removed) was obtained. Compared with that of the control test, the process configuration decreased the excess sludge production by 51.3%.展开更多
Efficient and environmentally sound treatment of soybean processing wastewater sludge is importance for industrial sustainability.Bioconversion by black soldier fly larvae(BSFL)has been extensively applied in biowaste...Efficient and environmentally sound treatment of soybean processing wastewater sludge is importance for industrial sustainability.Bioconversion by black soldier fly larvae(BSFL)has been extensively applied in biowaste recycling because of its efficacy and production of high-value outputs.However,the performance and underlying bacterial drivers of the BSFL-mediated sludge bioconversion require further investigation.This study investigated the larval bioconversion of the sludge,emphasizing waste reduction,larval quality,and the relationship between these aspects and bacterial communities.The inoculation with BSFL remarkably enhanced the reduction in the initial substrate(i.e.,sludge plus wheat bran as the bulking material).This intervention also yielded a high larval bioconversion rate of approximately 22%along with a higher larval crude protein content ranging from 45%-48% and a 17 amino acid to protein ratio of 86%-92%.Higher dissolved organic carbon concentrations(15-22 g/kg),coupled with lower germination indices(<5%),indicated that the residues retained biological instability after the bioconversion and required further composting.The potential risk of heavy metal pollution from mature larvae may not be a concern when used as aquaculture feed.The larval gut exhibited a higher bacterial diversity than the residues.Ammonium concentration increased with wheat bran and was positively correlated with the genera Lysinibacillus and Castellanella.Diverse gut bacteria(Olivibacter,Paracoccus)primarily facilitated notable sludge reduction.Sphingobacteria,Acinetobacter and Glutamicbacter played key roles in larval growth traits(biomass,protein,and amino acids).This study indicated that the valorization of soybean-processing-sourced sludge was achieved via functionally important BSFL intestinal microbiota,providing an efficient recycling approach for similar waste streams.展开更多
There are good prospects for phosphorus recovery from excess sludge by vivianite crystallization while a large number of extracellular polymeric substances in sludge will have impact on vivianite precipitation.In this...There are good prospects for phosphorus recovery from excess sludge by vivianite crystallization while a large number of extracellular polymeric substances in sludge will have impact on vivianite precipitation.In this study,as a representative of extracellular polymeric substance,the effect of sodium alginate(SA)on phosphorus recovery by vivianite precipitation under different initial SA concentrations(0–800 mg/L),p H values(6.5–9.0)and Fe/P molar ratios(1:1–2.4:1)was investigated using synthetic wastewater.The results showed that SA in low concentrations(≤400 mg/L)had little inhibitory effect on the phosphorus recovery rate.However,when the concentration of SA was larger than 400 mg/L,the phosphorus recovery rate decreased significantly with increasing SA concentrations.The inhibition rate of 800 mg/L SA was about 3 times as large as that of 400 mg/L SA.It was worth noting that the inhibitory effect of SA on vivianite precipitation decreased with increasing initial p H and Fe/P molar ratios.Additionally,SA has no obvious influence on the composition of products,but the morphology of harvested crystals was transformed from branches to plates or rods in uneven sizes.展开更多
Performance of biological phosphorus removal in the oxic-settling-anaerobic(OSA) process was investigated. Cell staining and fluorescent in situ hybridization(FISH) were used to analyze characteristics and microbial c...Performance of biological phosphorus removal in the oxic-settling-anaerobic(OSA) process was investigated. Cell staining and fluorescent in situ hybridization(FISH) were used to analyze characteristics and microbial community of sludge. Experimental results showed that phosphorus removal efficiency was near 60% and the amount of biological phosphorus accumulation in aerobic sludge of the OSA system was up to 26.9 mg/g. Biological phosphorus removal efficiency was partially inhibited by carbon sources in the continuous OSA system. Contrasted to the OSA system,biological phosphorus removal efficiency was enhanced by 14% and the average total phosphorus(TP) contents of aerobic sludge were increased by 0.36 mg/g when sufficient carbon sources were supplied in batch experiments. Staining methods indicated that about 35% of microorganisms had typical characteristics of phosphorus accumulating organisms(PAOs) . FISH analysis demonstrated that PAOMIX-binding bacteria were predominant microbial communities in the OSA system,which accounted for around 28% of total bacteria.展开更多
文摘Anaerobic digestion(AD)is widely employed for sludge stabilization and waste reduction.However,the slow hydrolysis process hinders methane production and leads to prolonged sludge issues.In this study,an efficient and eco-friendly lysozyme pre-treatment method was utilized to address these challenges.By optimizing lysozyme dosage,hydrolysis and cell lysis were maximized.Furthermore,lysozyme combined with hydrothermal pretreatment enhanced overall efficiency.Results indicate that:(1)When lysozyme dosage reached 90 mg/g TS after 240 min of pretreatment,SCOD,soluble polysaccharides,and protein content reached their maxima at 855.00,44.09,and 204.86 mg/L,respectively.This represented an increase of 85.87%,365.58%,and 259.21%compared to the untreated sludge.Threedimensional fluorescence spectroscopy revealed the highest fluorescence intensity in the IV region(soluble microbial product),promoting microbial metabolic activity.(2)Lysozyme combined with hydrothermal pretreatment significantly increased SCOD,soluble proteins,and polysaccharide release from sludge,reducing SCOD release time.Orthogonal experiments identified Group 3 as the most effective for SCOD and soluble polysaccharide release,while Group 9 released the most soluble proteins.The significance order of factors influencing SCOD,soluble proteins,and polysaccharide release is hydrothermal temperature>hydrothermal time>enzymatic digestion time.(3)The lysozyme-assisted hydrothermal pretreatment group exhibited the fastest release and the highest SCOD concentration of 8,135.00 mg/L during anaerobic digestion.Maximum SCOD consumption and cumulative gas production increased by 95.89%and 130.58%,respectively,compared to the control group,allowing gas production to conclude 3 days earlier.
文摘The innovative process consists of biological unit for wastewater treatment and ozonation unit for excess sludge treatment. An aerobic membrane bioreactor(MBR) was used to remove organics and nitrogen, and an anaerobic reactor was added to the biological unit for the release of phosphorus contained at aerobic sludge to enhance the removal of phosphorus. For the excess sludge produced in the MBR, which was fed to ozone contact column and reacted with ozone, then the ozonated sludge was returned to the MBR for further biological treatment. Experimental results showed that this process could remove organics, nitrogen and phosphorus efficiently, and the removals for COD, NH 3-N, TN and TP were 93.17%, 97.57%, 82.77% and 79.5%, respectively. Batch test indicated that the specific nitrification rate and specific denitrification rate of the MBR were 1.03 mg NH 3-N/(gMLSS·h) and 0.56 mg NOx-N/(gMLSS·h), and denitrification seems to be the rate-limiting step. Under the test conditions, the sludge concentration in the MBR was kept at 5000—6000 mg/L, and the wasted sludge was ozonated at an ozone dosage of 0.10 kgO 3/kgSS. During the experimental period of two months, no excess sludge was wasted, and a zero withdrawal of excess sludge was implemented. Through economic analysis, it was found that an additional ozonation operating cost for treatment of both wastewater and excess sludge was only 0.045 RMB Yuan(USD 0.0054)/m 3 wastewater.
文摘The releasing characteristics of phosphorus, nitrogen compounds, organics, and some metal cations during thermal treatment of excess sludge were investigated. It was found that during heating not only phosphorus, but also nitrogen compounds, organics, and some metal cations could be released in abundance. The maximum orthophosphate （ortho-P） release of about 90 mg/L in concentration was observed at 50℃ in 1 h. Except for volatile fatty acids （VFAs）, comparatively little total nitrogen （TN）, total organic carbon （TOC）, and metal cations were released at the same time. Such results might favor further process of phosphorus recovery. VFAs were considerably released only at 50℃. Acetic, butyric, and propionic acid were the most abundant components in turn and their releasing profiles exhibited good linear relationship with time （R2 = 0.9977, 0.9624, and 0.8908, respectively）. The concentrations of Mg^2＋ and K^＋ increased with time and temperature during thermal treatment, but Ca^2＋ decreased. The release of Mg^2＋ and K^＋ agreed well with TP release （R^2 = 0.9892 and 0.9476, respectively）. Temperature in the experimental range had very little impact on the linear relationships, especially of Mg^2＋. Moreover, the parameter of mixed liquor suspended solids （MLSS） was found to be an important factor for thermal sludge treatment as the released ortho-P and total phosphorus （TP） at 50℃ increased more than one-fold when MLSS was increased from 4000 to 8000 mg/L.
文摘Domestic wastewater was treated by combined anaerobic biofilm aerobic membrane bioreactor(MBR) process, and part biomass in MBR was withdrawn to treat with ozone, then the ozonated sludge was returned to anaerobic inlet. In aerobic MBR, MLSS and DO were controlled at 3000—3500 mg/L and 0 8 mg/L respectively. Comparing the experimental results of two stages, it was noticed that ozonation did not affect the removal efficiency for organics but had a significant influence on the removals of NH 3 N and TN. During the ozonation period of two months, no excess sludge was wasted, and a zero sludge yield was obtained.
文摘In order to enhance the efficiency of aerobic digestion, the excess sludge was irradiated by low intensity ultrasound at a frequency of 28 kHz and acoustic intensity of 0.53 W/cm^2. The results show that the sludge stabilization without ultrasonic treatment can be achieved after 17 d of digestion, whereas the digestion time of ultrasonic groups can be cut by 3-7 d. During the same digestion elapsing, in ultrasonic groups the total volatile suspended solid removal rate is higher than that in the control group. The kinetics of aerobic digestion of excess sludge with ultrasound can also be described with first-order reaction.
基金supported by the National Natural Science Foundation of China(No.51938010)the Major Science and Technology Projects for Water Pollution Control and Treatment of China(No.2017ZX07205002)+1 种基金National Key Research and Development Programme of China(No.2016YFC0401103)the Jiangsu Collaborative Innovation Center of Technology and Material of Water Treatment。
文摘Recently,more and more attention has been paid to the strong oxidation ability of newly prepared potassium ferrate(NAPF) in sludge reduction process,but less attention has been paid to the change of phosphorus in this process.The feasibility of phosphorus migration and transformation during excess sludge reduction pretre atment using NAPF pre-oxidation combined with anaerobic digestion was investigated.After 70 mg/g suspended solids NAPF pretreatment and 16 days anaerobic digestion,the solid-phase volatile suspended solids decreased by 44.2%,and much organic matter had been released into the liquid-phase and then degraded during digestion by indigenous microorganisms.As the sludge pre-oxidation process was performed,solid-phase organic phosphorus and chemically combined phosphorus also released into the liquid-phase as PO4^3-,peaking at 100 mg/L.During anaerobic digestion,the Fe3+in the liquid-phase was gradually reduced to Fe2+,and then formed Fe^2+-PO4^3- compound crystals and re-migrated to the solid-phase.The concentration of PO4^3- decreased to 17.08± 1.1 mg/L in the liquid-phase after anaerobic digestion.Finally,the phosphorus in the Fe^2+-PO4^3- compound accounts for 80% of the total phosphorus in the solid-phase.A large number of vivianite crystals in sludge were observed.Therefore,this technology not only effectively reduces sludge,but also increases the proportion of PO43-in the sludge in the form of Vivianite.
基金Supported by the National Natural Science Foundation of China(50978029,51008023)
文摘A group of Zn-Al layered double hydroxides (LDHs) were synthesized at different temperatures from 25-90 °C in order to investigate the influence of synthesis temperature on characteristics of the LDHs and their phosphate adsorption behaviour. The results reveal that an increase in the synthesis temperature generally improves the specific surface area of the sample and the phosphate adsorption capacity. The significantly enhanced crystallin- ity of the Zn-Al-30, synthesized at 30 °C, leads to a remarkable decrease in the specific surface area and consequently a poor phosphate adsorption capacity. It is suggested that the surface adsorption plays an important role in the phosphate uptake by the Zn-Al LDHs. Zn-Al-70 presents a relatively higher crystallinity and a lower specific surface area, compared with Zn-Al-60 and Zn-Al-80, but the highest phosphate adsorption capacity, indicating that surface adsorption is only one of the pathways for phosphate removal. The phosphate adsorption by the Zn-Al follows a pseudo-second-order kinetic equation. The adsorption isotherms fit Langmuir models, and the maximum a dsorption capacities of the Zn-Al-25, Zn-Al-50 and Zn-Al-70 are estimated to be 17.82, 21.01 and 27.10 mg·g-1 adsorbent, respectively.
基金Science and Technology Development Projects of Zhejiang Province and Hangzhou City,China(No.2007C13081,No.20062912A06)Key Decipline Open Foundation of Zhejiang University of Technology,China(No.20080210)
文摘To seek for an alternative solution for the treatment and disposal of excess activated sludge,a hybrid system of membrane bioreactor(MBR)coupled with ozonation process(i.e.,ozonation run)was set up to treat the domestic wastewater.A reference run without ozonation was also preformed as a control.The optimal ozone dose of 0.16mg O3·mg MLVSS-1 used for the sludge solubilization in the ozonation run was firstly determined through the batch sludge ozonation tests.A 40-day continuous operation of the two parallel systems demonstrated that circulation of ozonized sludge as lysate did not impact the performance of MBR in terms of organic and ammonia removal.On the contrary,an improvement in TN removal(by 7.7%)and sludge reduction(by 54%)was observed in the ozonation-combined MBR,and it was furthermore illustrated by the calculation of the mass balance based on the COD and TN substances.In addition,ozonation did not deteriorate the sludge activities for the ozonation run,indicating that not much inert organic materials built up in the bioreactor.Decreased VSS/SS ratio and lower amount of filamentous bacteria after ozonation treatment on the other hand improved the sludge settleability,as lower and constant Sluge Volume Index(SVI)values were detected in the ozonation run.
基金Supported by the Fundamental Research Funds for the Central Universities(2010380003161543)Science and Technology Project of Science and Technology Department of Guangdong Province,China(2010B031700023)
文摘In order to study the effect of excess sludge ozonation, a continuous experiment in lab scale process was carried out. During the treatment process, a high level of ozone was produced by the electrolysis-type ozone generator, and various parameters, such as Soluble Chemical Oxygen Demand （SCOD）, Mixed Liquor Suspended Solids （MLSS）, Mixed Liquor Volatile Suspended Solids （MLVSS）, pH and so on, which char- acterize sludge were investigated. A substantial reduction in the volume of sludge and the release of intracellular materials were observed： SCOD proliferated as a consequence of extending the ozone feeding time; MLSS and MLVSS, especially the ratio of MLVSS to MLSS, dwindled as the action time rose. Through analyzing the effluent quality and excess sludge activity, the sludge-water volume mixture ratio of 1 ： 20 with 50 -60 minutes＇ oxidation treatment was found to be the optimal condition for ozonic disintegration of excess sludge. A remarkable sludge reduction rate of 57% could be achieved under the ozone feeding time of 40 minutes, which revealed the optimal action time.
文摘In order to investigate the influence factors of zero excess activated sludge (EAS) process by ozonation, a 100 L membrane bioreactor coupled with a sludge ozonation unit (MBR-SO) was performed for 80 d without EAS wasting. Some mathematical models were developed to elucidate the relationship between process parameters and the operating effects. It is considered that the sludge lysing ratio (ξ), produced COD per unit mass lysed MLSS (η), observed sludge yield coefficient (Yobs) and intrinsic yield coefficient for COD produced by lysed sludge (Y2) significantly affect the flowrate to ozonation unit (q). When q is 0.0067 times of influent flowrate (Q) and ξ is about 0.72 for each batch ozonation, a relatively stable MLSS concentration of 8168 mg/L and zero Yobs are achieved in the MBR-SO system. The calculation of sludge disintegration number indicates that the high ξ can apparently decrease the sludge amount needed for ozonation. At the same ozone dose, the low input ozone concentration and high flowrate can enhance the sludge lysing effects and a low energy consumption of 0.041 Yuan/m3 wastewater is obtained.
基金supported by the“Pioneer”and“Leading Goose”R&D Program of Zhejiang(No.2023C03149).
文摘Anaerobic fermentation is an efficient method to extract phosphorus from excess sludge,thereby facilitating its recovery and mitigating the phosphorus resource shortage.However,the prevalent metal-bound phosphorus species within sludge was difficult to release into the fermentation liquor.To address this,this study evaluated the enhanced phosphorus release performance from sludge containing iron-phosphorus compounds(Fe-P)via co-fermenting it with agriculture wastes.Specifically,protein-rich feather(Feather Group)and polysaccharide-rich tea residue(Tea Group)was respectively dosed into batch-scale fermentation jar.Results showed that the Feather Group exhibited significantly higher levels of released soluble phosphorus(2.1 folds)and volatile fatty acids(41.4 folds)compared to the Control Group,with concentrations reaching up to 280 mg/L and 9366 mg chemical oxygen demand/L,respectively.The activities ofα-glucosidase,neutral protease and acetate kinase in the Feather group were increased by 11.1%,92.3%and 37.6%,respectively,compared with the Control group.Methanogen abundance decreased while hydrolytic acid-producing bacteria and iron-reducing bacteria increased significantly after supplying agricultural wastes.Metagenomic analysis demonstrated a significant increase in genes related to acetic acid synthesis.Mechanism elucidation suggested that increased iron-reducing bacteria abundance promoted Fe3+reduction into Fe2+,thus enhancing phosphorus release from Fe-P compounds.This work may provide valuable information for developing effective strategy to extract phosphorus resource from complex environmental wastes.
基金This work was supported by the Key Technologies Research and Development Program of the Tenth Five-Year Plan of Anhui Province(Grant No.04013029)the Research Foundation of Hefei University of Technology(Grant No.050801F).
文摘In order to study the minimization of excess sludge production,the reduction in the excess sludge production in the presence of an inhibitor and uncoupler was studied in this work.The experimental results show that such an addition could effectively reduce the production of excess sludge.With the energy uncoupling model established in this work,energy uncoupling coefficient(Eu)was used to evaluate the reduction in excess sludge production.The energy uncoupling coefficients in the presence of dinitrophenol(dNP),Zn^(2+),and Cu^(2+)was 0.75,0.46,and 0.18,respectively.The analysis demonstrated that energy spilling occurred in the presence of dNP,and that dNP was an effective uncoupler for reducing the production of excess activated sludge without affecting the microbial respiration activity.
基金supported by the Key R&D Projects of the Sichuan Provincial Department of Science and Technology in 2022 (No.2022YFS0457)Innovation and Entrepreneurship Training Program for College Students (No.202210649050).
文摘Thermal alkaline hydrolysis is a common pretreatment method for the utilization of excess activated sludge(EAS).Owing to strict environment laws and need for better energy utilization,new methods were developed in this study to improve the efficiency of pretreatment method.Direct thermal hydrolysis(TH),pasteurized thermal hydrolysis(PTH),and alkaline pasteurized thermal hydrolysis(PTH+CaO and PTH+NaOH)methods were used to treat EAS.Each method was compared and analyzed in terms of dissolution in ammonium nitrogen(NH_(4)^(+)-N)and soluble COD(SCOD)in EAS.Furthermore,the removal of tetracycline resistance genes(TRGs)and class 1 transposon gene intI1 from EAS was investigated.The NH_(4)^(+)-N and SCOD concentrations in EAS treated by PTH were 1.24 and 2.58 times higher than those of TH.However,the removal efficiency of total TRGs and intI1 between the groups was comparable.The SCOD concentration of the PTH+NaOH group was 4.37 times higher than that of the PTH group,and the removal efficiency of total TRGs was increased by 9.52%compared with that by PTH.The NH_(4)^(+)-N and SCOD concentrations of the PTH+CaO group could reach 85.04%and 92.14%of the PTH+NaOH group,but the removal efficiency of total TRGs by PTH+CaO was 19.78%lower than that by PTH+NaOH.Thus,to reduce the financial cost in actual operation,lime(CaO)can be used instead of a strong alkali(NaOH),and pasteurized steam at 70℃ instead of conventional high-temperature heating to treat EAS.This study provides a reference for the development of alkaline hydrolysis under moderate temperatures along with the removal of TRGs in EAS.
基金Innovation Program of Shanghai Municipal Education Commission,China(No.12zz069)Shanghai Municipal Natural Science Foundation,China(No.11ZR1400400)Fundamental Research Funds for the Central Universities,China(No.12D11303)
文摘A study was undertaken to investigate the production of amino acids from excess activated sludge (EAS) by enzymatic hydrolysis. Firstly, the protein was extracted from EAS. Secondly, the protein solution was further hydrolyzed under free enzyme or immobilized enzyme. The reversed phase high performance liquid chromatography (RP-HPLC) and inductively coupled plasma emission spectrometer (ICP) were applied to determine the contents of amino acids and heavy metals, respectively. The effects of enzyme/substrate(E/S), pH, temperature, and reaction time were investigated in detail. The results indicated that, the optimum conditions for protein hydrolysis were temperature 55℃, pH 10, E/S 9 g/L, and reaction time 8 h, and the highest yield of amino acids was more than 10 g/100 g dry sludge (DS) under free enzyme. Moreover, the security and nutrition were taken into consideration. There were seven kinds of essential amino acids and ten non-essential amino acids in the raw amino acid (RAA) solution, and the contents of heavy metals were lower, living up to Hygienical standard for feeds (China). This technology widens the source of amino acids and makes the extraction of amino acids from EAS more economic and effective.
文摘Sludge concentration subarea(A area and B area) is realized by mesh filter unit,solving the higher sludge concentration process problem of MBR system under zero excess sludge discharge conditions.Mass balance of the system is processed,and variety disciplinarians of VSS of A area and B area are analyzed.The results show that XA decreases while HRTA increases.XB decreases while R increases,and ascends as VSS(XA,B) of mesh effluent increases.When XB is a fixed value,XA,B increases as R does and XA decreases slowly while R increases,which theoretically proves the feasibility of the technique.
文摘To investigate the effects of ozonation on minimizing the excess sludge and enhancing the nitrogen removal in an effluent, batch and continuous experiments in two MBRs with and without sludge ozonation （ namely combined and reference run） were carried out. Through ozonation at a dose of 0. 16 mg O3/mg MLVSS, 53.1% of the treated MLVSS was solubilized, and soluble SCOD/TN ratio of ozonized sludge （OS） was about 8. 6 due to the release of cellular nitrogen-contained materials and SCOD loss by ozone mineralization. In addition, the results of batch nitrification and denitrification tests with OS supernatant indicated that solubilized sludge could act as a reducing power for denitrification and a nitrogen source for nitrification. 40-day operation of-two MBR systems demonstrated that the recirculation of OS into a bioreaetor enabled the combined system have two advantages over the control one. The observed sludge yield （Yobs） was decreased from 0. 13 to 0. 06g MLSS/g COD, while the nitrogen removal was increased from 64. 6% to 72. 3%. And sludge ozonation elevated the inorganic fraction of MLSS, but did not impact sludge activities.
文摘Based on the hypothesis of reducing sludge production under cryptic growth conditions, ozone was used as cell lysis agent to treat excess sludge,and then the ozonated supernatant was returned to the aeration tank. The results show that COD and NH+4-N removal efficiencies in ozonation process were 87.96% and 84.42%, respectively. Meanwhile, a low excess sludge yield coefficient of 0. 113 ( g SS/g COD removed) was obtained. Compared with that of the control test, the process configuration decreased the excess sludge production by 51.3%.
基金supported financially from the Shenzhen Civic Administration and Regulation Bureau of China,the National Natural Science Foundation of China(No.22176005)the Key R&D Program of Hebei Province,China(No.22327312D).
文摘Efficient and environmentally sound treatment of soybean processing wastewater sludge is importance for industrial sustainability.Bioconversion by black soldier fly larvae(BSFL)has been extensively applied in biowaste recycling because of its efficacy and production of high-value outputs.However,the performance and underlying bacterial drivers of the BSFL-mediated sludge bioconversion require further investigation.This study investigated the larval bioconversion of the sludge,emphasizing waste reduction,larval quality,and the relationship between these aspects and bacterial communities.The inoculation with BSFL remarkably enhanced the reduction in the initial substrate(i.e.,sludge plus wheat bran as the bulking material).This intervention also yielded a high larval bioconversion rate of approximately 22%along with a higher larval crude protein content ranging from 45%-48% and a 17 amino acid to protein ratio of 86%-92%.Higher dissolved organic carbon concentrations(15-22 g/kg),coupled with lower germination indices(<5%),indicated that the residues retained biological instability after the bioconversion and required further composting.The potential risk of heavy metal pollution from mature larvae may not be a concern when used as aquaculture feed.The larval gut exhibited a higher bacterial diversity than the residues.Ammonium concentration increased with wheat bran and was positively correlated with the genera Lysinibacillus and Castellanella.Diverse gut bacteria(Olivibacter,Paracoccus)primarily facilitated notable sludge reduction.Sphingobacteria,Acinetobacter and Glutamicbacter played key roles in larval growth traits(biomass,protein,and amino acids).This study indicated that the valorization of soybean-processing-sourced sludge was achieved via functionally important BSFL intestinal microbiota,providing an efficient recycling approach for similar waste streams.
基金supported by the State Key Laboratory of Eco-hydraulics in the Northwest Arid Region of China(No.2016ZZKT-8)。
文摘There are good prospects for phosphorus recovery from excess sludge by vivianite crystallization while a large number of extracellular polymeric substances in sludge will have impact on vivianite precipitation.In this study,as a representative of extracellular polymeric substance,the effect of sodium alginate(SA)on phosphorus recovery by vivianite precipitation under different initial SA concentrations(0–800 mg/L),p H values(6.5–9.0)and Fe/P molar ratios(1:1–2.4:1)was investigated using synthetic wastewater.The results showed that SA in low concentrations(≤400 mg/L)had little inhibitory effect on the phosphorus recovery rate.However,when the concentration of SA was larger than 400 mg/L,the phosphorus recovery rate decreased significantly with increasing SA concentrations.The inhibition rate of 800 mg/L SA was about 3 times as large as that of 400 mg/L SA.It was worth noting that the inhibitory effect of SA on vivianite precipitation decreased with increasing initial p H and Fe/P molar ratios.Additionally,SA has no obvious influence on the composition of products,but the morphology of harvested crystals was transformed from branches to plates or rods in uneven sizes.
基金Project (No. 2006BAC19B04) supported by the National Key Technology R&D Program of China
文摘Performance of biological phosphorus removal in the oxic-settling-anaerobic(OSA) process was investigated. Cell staining and fluorescent in situ hybridization(FISH) were used to analyze characteristics and microbial community of sludge. Experimental results showed that phosphorus removal efficiency was near 60% and the amount of biological phosphorus accumulation in aerobic sludge of the OSA system was up to 26.9 mg/g. Biological phosphorus removal efficiency was partially inhibited by carbon sources in the continuous OSA system. Contrasted to the OSA system,biological phosphorus removal efficiency was enhanced by 14% and the average total phosphorus(TP) contents of aerobic sludge were increased by 0.36 mg/g when sufficient carbon sources were supplied in batch experiments. Staining methods indicated that about 35% of microorganisms had typical characteristics of phosphorus accumulating organisms(PAOs) . FISH analysis demonstrated that PAOMIX-binding bacteria were predominant microbial communities in the OSA system,which accounted for around 28% of total bacteria.
