The hydrophobic flocculation of marmatite fines in aqueous suspensions induced by butyl xanthate （KBX） and ammonium dibutyl dithiophosphate （ADD） was investigated using laser particle size analysis, microscopy ana...The hydrophobic flocculation of marmatite fines in aqueous suspensions induced by butyl xanthate （KBX） and ammonium dibutyl dithiophosphate （ADD） was investigated using laser particle size analysis, microscopy analysis, electrophoretic light scattering, contact angle measurement and infrared spectroscopy. The studies were performed on single minerals with size 〈20 μm by varying several parameters, including pH, collector concentration and kerosene addition. The results show that the floc fotation closely correlated with the size of flocs and the particle hydrophobicity, but was not lowered with increasing the particle surface charges due to collector adsorption. Under good operating conditions, the floc flotation of marmatite fines as a function of KBX and ADD can all reach floatability over 90%, in comparison with conventional flotation obtaining floatability of about 60%. It also has been found that a small addition of kerosene greatly improved the floc flotation because of the formation of oil films on marmatite particles. The results of FTIR spectra indicate that adsorption of the two collectors onto marmatite were chemical adsorption.展开更多
Butyl hydroxyanisole(BHA) is usually blended with other synthetic antioxidants to improve the antioxidative property due to synergistic antioxidation. However, the synergistic antioxidation mechanisms of BHA with syne...Butyl hydroxyanisole(BHA) is usually blended with other synthetic antioxidants to improve the antioxidative property due to synergistic antioxidation. However, the synergistic antioxidation mechanisms of BHA with synergists have not been revealed yet. Thus, the antioxidation of BHA with butylated hydroxytoluene(BHT), tert-butylhydroquinone(TBHQ), or propyl gallate(PG) was investigated in the 2,2-azobis(2-amidino-propane) dihydrochloride oxidizing system. The contents of BHA, BHT, TBHQ,PG, and transformation products were measured by high-performance liquid chromatography. Transformation products were identified with liquid chromatography-mass spectrometry and gas chromatography–mass spectrometry. Results showed that synergistic antioxidation occurred between BHA and BHT, TBHQ, or PG. The synergistic antioxidation effect of BHA and BHT was attributed to the regeneration of BHA by BHT. Transformation products of BHA and BHT(compounds 6 and 7, dimers of BHA and BHT) had little contribution due to the relatively low content(<0.6%). The synergistic antioxidation effect of BHA and TBHQ or BHA and PG was attributed to the protective mechanism of TBHQ or PG on BHA. No transformation products were detected of BHA and TBHQ. Transformation products of BHA and PG(compounds 9 and 10, dimers of BHA and PG) had limited contribution due to the relatively low percentage(<7%). Therefore, BHA and BHT performed competitive antioxidation,while BHA and TBHQ or PG performed protective antioxidation.展开更多
The effects of galvanic interaction between galena and pyrite on their flotation and electrochemical characters were studied by electrochemical,adsorption,flotation and FTIR techniques,respectively.Electrochemical tes...The effects of galvanic interaction between galena and pyrite on their flotation and electrochemical characters were studied by electrochemical,adsorption,flotation and FTIR techniques,respectively.Electrochemical tests indicate that galena is electrochemically more active than pyrite and serves as an anode in galvanic combination with pyrite.The galvanic current density from a mixture of galena and pyrite is 4 times as high as the self corrosion current density of galena,which indicates that the corrosion rate of galena is accelerated.Adsorption tests show that the adsorption of butyl xanthate on galena surface is enhanced,and affected by a combination of pyrite-galena mixtures and conditioning time.Compared with individual mineral particles,galvanic interaction reduces the floatability difference between galena and pyrite.The flotation recovery of galena decreases while that of pyrite increases when two minerals are mixed together due to the influence of galvanic interaction on the formation of hydrophilic/hydrophobic product.The FTIR results show that the formation of dixanthogen on pyrite surface is depressed due to the galvanic interaction.展开更多
Results of oxidation 2-(N-acetylamine)-3-(3,5-di-tert-butyl-4-hydroxyphenyl)-propionic acid oxygen depend on temperature. At 55℃?- 60℃, 2,4-di-tert-butylbicyclo(4,3,1)deca-4,6-dien-8-(N-acetylamine)-3,9-dion-1-oxa i...Results of oxidation 2-(N-acetylamine)-3-(3,5-di-tert-butyl-4-hydroxyphenyl)-propionic acid oxygen depend on temperature. At 55℃?- 60℃, 2,4-di-tert-butylbicyclo(4,3,1)deca-4,6-dien-8-(N-acetylamine)-3,9-dion-1-oxa is formed. The constitution is based on dates of spectrums 1Н and 13С NMR. At 95℃?- 97℃, mixtures of 2,4-di-tert-butylbicyclo(4,3,1)deca-4,6-dien-8-(N-acetylamine)-3,9-dion-1-oxa and of 6,8-di-tert-butyl-3-(N-acetylamine)spiro(4,5)deca-1-oxa-5,8-dien-2,7-dione are produced. Structures are calculated by the method of Hartrii-Foka. Values of enthalpies and of entropies allow to assume dynamic isomerism.展开更多
The catalytic activities of some heteropolyacids(HPAs) in synthesizing butyl acrylate are reported. It has been demonstrated that 12 tungstophosphoric acid is the most effective catalyst among more than 20 HPA(s...The catalytic activities of some heteropolyacids(HPAs) in synthesizing butyl acrylate are reported. It has been demonstrated that 12 tungstophosphoric acid is the most effective catalyst among more than 20 HPA(salts). Various factors concerned in this reaction have been investigated. The optimum conditions have been found, that is, the molar ratio of alcohol to acid is 1.2∶1.0 , the catalyst concentration 1%(mass fraction), the reaction time 2 h, the temperature 98—124 ℃ and a certain amount of polymerization inhibitor exists.展开更多
[ Objective ] The paper was to study the factors influencing the synthesis of butyl polyglycosides and its synthesis kineties. [ Method ] In the synthesis process of alkyl polyglycosides by transglyeosidation method, ...[ Objective ] The paper was to study the factors influencing the synthesis of butyl polyglycosides and its synthesis kineties. [ Method ] In the synthesis process of alkyl polyglycosides by transglyeosidation method, p-toluenesulfonie acid and stearie acid were used as composite catalyst, intermediate product butyl polyglycosides was prepared via reactive distillation technology. [ Result ] The suitable preparation conditian of butyl polyglyeasides was as follows： catalyst usage, 1.2 g（ p-toluenesulfoni ：stearie acid = 6：1 ） ; reaction temperature, 110 ℃ ; the ratio of butanol and glucose, 8： 1. The results showed that the larger the molar ratio of butanol and glucose was,the more the butyl monoside content was, and the less the polymerizatian degree of butyl glyeasides was. The catalyst usage and reaction temperature had little influence on the component of butyl polyglyeesides. With the increase of catalyst usage or reaction temperature,the reaction time was shortened dramatically. The kinetic equation for the synthesis of butyl glueeside was finally obtained as follows： -dCA/dt =0.163 7exp（ -1. 968×10^3/RT）CA -0.003 49 exp （ -2.727×10^3/RT） Ce. [ Conclusionl The suitable condition for the preparation of butyl polyglyeasides and its synthesis kinetic equation obtained in the study could provide theoretical basis for the synthesis of long-chain alkyl polyglyeasides.展开更多
The vapor-liquid equilibrium of binary mixtures of propyl acetate, butyl acetate and isobutyl acetate with meth- anol has been determined at a constant pressure of 0.6 MPa. Results have been modeled with the Peng-Robi...The vapor-liquid equilibrium of binary mixtures of propyl acetate, butyl acetate and isobutyl acetate with meth- anol has been determined at a constant pressure of 0.6 MPa. Results have been modeled with the Peng-Robinson equation, a traditional cubic equation of state widely employed in chemical industries, as well as with the perturbed-chain statistical associating fluid PC-SAFT theory of Gross-Sadowski. By correlation of the binary inter- action parameters of these equations, the measured vapor-liquid equilibrium data can be accurately predicted. Thus, this work shows that these models are able to represent the experimental data for systems with associating comoounds via hydrogen bonding.展开更多
The separation of ternary methanol/methyl butyl ether/1-butylchloride mixtures was investigated, which are the main components of the waste liquid. After preliminary studies on the ternary system, the integrated proce...The separation of ternary methanol/methyl butyl ether/1-butylchloride mixtures was investigated, which are the main components of the waste liquid. After preliminary studies on the ternary system, the integrated process of extraction and distillation was put forward to separate the ternary system. The results show that methanol carl be removed from the mixtures by extraction using water as the extracting agent. Through distillation of extract and dried raffinate respectively, methanol, methyl butyl ether and 1-butylchloride can be separated and recovered. In addition, the optimal volume for the extracting agent and effects of reflux ratio on the yield of product were also studied. The optimal volume ratio of the extracting agent to material is 1： 3.5, and the yield of the product increases with the increase of reflux ratio.展开更多
A novel macrocyclic complex 2{[（n-Bu2Sn）4O2-L2]2DMF} was synthesized by the reaction of 4-（1,2- dithioethylene）methylene-3,5-disoxo-1,6-heptadiene-1,7-dis-（o-formy~）-dis-p-phenoxyacetic acid（LH2, compound 1） w...A novel macrocyclic complex 2{[（n-Bu2Sn）4O2-L2]2DMF} was synthesized by the reaction of 4-（1,2- dithioethylene）methylene-3,5-disoxo-1,6-heptadiene-1,7-dis-（o-formy~）-dis-p-phenoxyacetic acid（LH2, compound 1） with di-n-butyltin oxide. Compound 1 and complex 2 were characterized by elemental analysis, FTIR spectroscopy, and ~H NMR spectroscopy. The crystal structure of complex 2 was determined by single crystal X-ray diffraction analysis. There are two crystallographic independent molecules in complex 2, and each molecule structure is centro-symmetric and features a central rhombus cyclic Bu4Sn2O2 unit with two exocyclic Sn atoms linked at the O atoms of the four-membered ring. In molecule A, the four Sn atoms are five-coordinated. However, in molecule B, the four Sn atoms have two different coordination geometries, the endocyclic Sn atoms are five-coordinated and the exocyclic Sn atoms are four-coordinated. The dicarboxylate ligands in molecules A and B bridge exocylic or endocyclic tin atoms, forming two macroheterocycles with 26 atoms. Pilot studies have indicated that complex 2 has good anti- bacterial and antitumour activities.展开更多
Use of free air as oxidant and copper（II）chloride as catalyst,3,3＇-di-tert-butylbi-phenyl-2,5,2＇,5＇-diquinone（BBDQ）was prepared via catalytic oxidation of 2,2＇-dihydroxy-3,3＇-di-tert-butyl-5,5＇-dimethoxy-bip...Use of free air as oxidant and copper（II）chloride as catalyst,3,3＇-di-tert-butylbi-phenyl-2,5,2＇,5＇-diquinone（BBDQ）was prepared via catalytic oxidation of 2,2＇-dihydroxy-3,3＇-di-tert-butyl-5,5＇-dimethoxy-biphenyl（di-BHA）.The yield of reaction attained 95% and the selectivity for BBDQ was 100%.The single-crystal X-ray diffraction analysis reveals that the dihedral angle between two rings（benzene rings for di-BHA and quinone rings for BBDQ）changes from 89.8 to 45.3o,indicating the steric hindrance effects of methyl disappear in the oxidation process.The crystal structures of di-BHA and BBDQ are further confirmed by their spectral characterizations.The probable mechanism for this oxidation process is also discussed.展开更多
On an example of spontaneous changes 5,7-di-tert-butylspiro (2,5) octa-4,7-diene-6-one at room temperature, a new example of condensations in a solid station is opened. The single crystal of 2-(3’, 5'-di-tert-but...On an example of spontaneous changes 5,7-di-tert-butylspiro (2,5) octa-4,7-diene-6-one at room temperature, a new example of condensations in a solid station is opened. The single crystal of 2-(3’, 5'-di-tert-butyl-4'-hydroxy-phenyl)-ethyloxy-p-cresole is produced as result of a structure transformation 5,7-di-tert-butylspiro (2,5) octa-4,7-diene-6-one in a solid phase at room temperature except a single crystal at transformation 5,7-di-tert-butylspiro (2,5) octa-4,7-diene-6-one a new substance is formed too. Spectrums 1Н and 13С NMR differ from similar spectrums of initial compound and the single crystal. New substance represents an admixture of isomeric compounds, capable reversible to be transformed in initial 5,7-di-tert-butylspiro(2,5) octa-4,7-diene-6-one and 2-(3’, 5'-di-tert-butyl-4'-hydroxyphenyl)-ethyloxy-p-cresole.展开更多
Objective The aim of the present study was to investigate the effects of paternal Di‐N‐butyl‐phthalate （DBP） exposure pre‐ and postnatally on F1 generation offspring,and prenatally on F2 generation offspring.Met...Objective The aim of the present study was to investigate the effects of paternal Di‐N‐butyl‐phthalate （DBP） exposure pre‐ and postnatally on F1 generation offspring,and prenatally on F2 generation offspring.Methods Male mice were exposed to either 500 mg/kg or 2 000 mg/kg of DBP for 8 weeks,and mated with non‐exposed females.Three‐quarters of the females were sacrificed a day prior to parturition,and examined for the number of living and dead implantations,and incidence of gross malformations.Pups from the remaining females were assessed for developmental markers,growth parameters,as well as sperm quantity and quality.Results There were no changes in the fertility of parents and in intrauterine development of the offspring.Pups of DBP‐exposed males demonstrated growth‐retardation.Following paternal exposure to 500 mg/kg bw of DBP,there were almost twice the number of males than females born in the F1 generation.F1 generation females had a 2.5‐day delay in vaginal opening.Paternal exposure to 2 000 mg/kg bw of DBP increased the incidence of sperm head malformations in F1 generation males;however,there were no changes in the fertility and viability of foetuses in the F2 generation.Conclusion Paternal DBP exposure may disturb the sex ratio of the offspring,delay female sexual maturation,and deteriorate the sperm quality of F1 generation males.展开更多
[Objective] The aim of this study was to detect the acute toxicity of clethodim, cypermethrin and 2,4-D-butylate. [Method] Chironomus sinicus larvae were exposed to different concentrations of clethodim, cypermethrin ...[Objective] The aim of this study was to detect the acute toxicity of clethodim, cypermethrin and 2,4-D-butylate. [Method] Chironomus sinicus larvae were exposed to different concentrations of clethodim, cypermethrin and 2,4-D-butylate. Survival rate, lethal concentration 50 （LC50） and superoxide dismutase （SOD） activity in the homogenate of the larvae were monitored to detect the toxicity of the pesti- cides. [Result] The survival rates of C. sinicus larvae exposed to cypermethrin and 2,4-D-butylate for 12 h were almost unchanged at different concentrations, but de- creased with concentration increasing 48 h later. For each pesticide, the differences in survival rates of C. sinicus larvae at 48 h were significant. The 48 h LC50 of clethodim, cypermethrin and 2,4-D-butylate to C. sinicus larvae were 1.842, 0.150 and 1.999 mg/L, respectively. The acute toxicity of cypermethrin was the highest a- mong the three pesticides and that of 2,4-D-butylate was the lowest. Clethodim sig- nificantly reduced the SOD content in a dose-dependent manner. 2,4-D-butylate also reduced SOD content in C. sinicus larvae, but the reduction was not significantly re- lated to its dosage. However, cypermethrin showed no significant effect on SOD ac- tivity in C. sinicus larvae.展开更多
The catalytic performance of some quaternary ammonium salts for the liquid phase reaction of butanol and hydrochloric acid at different conditions was studied experimentally and compared with the traditional catalyst ...The catalytic performance of some quaternary ammonium salts for the liquid phase reaction of butanol and hydrochloric acid at different conditions was studied experimentally and compared with the traditional catalyst （ZnCl2）. The organic ammonium catalysts investigated include ionic liquids N-butyl-N-methyl imidazolium fluoborate （[BMIM][BF4]） and N-butyl-N-methylimidazolium chloride （[BMIM]Cl） as well as hydrochloric salts of N-methylimidazol （[HMIM]Cl）, pyridine （[HPy]Cl） and triethylamine （[HEt3N]Cl）. It is shown that the intrinsic catalytic performance of all organic ammonium salts except [HEt3N]Cl is slightly superior to ZnCl2, while the selectivity of butyl chloride is nearly at the same level around 96%. The conversion of butanol increases slightly with temperature and the catalyst amount added while the variation of selectivity is not obvious. Based on the recycle experiments, the ionic liquids as catalyst for the reaction of butanol and hydrochloric acid can be used more than 5 times, which suggests great potential of using ionic liquids as novel catalyst for such reactions.展开更多
In this paper,the effect of sodium butyl xanthate(NaBX)adsorption on the surface of bornite at different pH on flotation was studied by adsorption kinetic and thermodynamic.The flotation results demonstrated that the ...In this paper,the effect of sodium butyl xanthate(NaBX)adsorption on the surface of bornite at different pH on flotation was studied by adsorption kinetic and thermodynamic.The flotation results demonstrated that the recovery was the highest when pH was 9 in NaBX solution(4×10^?5 mol/L).The adsorption kinetics showed the reaction of NaBX on the bornite conformed to the second order kinetic equation;it belonged to the multimolecular layer adsorption of Freundlich model;the maximum adsorption rate constant was 0.30 g/(10^?6 mol·min),and the equilibrium adsorption capacity was 2.70×10^?6 mol/g.Thermodynamic calculation results indicated that the adsorption process was spontaneous chemisorption,and the adsorption products of NaBX on bornite surface were cupric butyl xanthate,ferric butyl xanthate and dixanthogen,which were confirmed by infrared spectrum measurements.展开更多
Montmorillonite(MMT) was modified by ultrasound and castor oil quaternary ammonium salt intercalation method to prepare a new type of organic montmorillonite(OMMT). The surface structure, particle morphology, interlay...Montmorillonite(MMT) was modified by ultrasound and castor oil quaternary ammonium salt intercalation method to prepare a new type of organic montmorillonite(OMMT). The surface structure, particle morphology, interlayer distance, and thermal behavior of the samples obtained were characterized. The modified OMMT was then added to chlorinated butyl rubber(CIIR) by mechanical blending, and a composite material with excellent damping properties was obtained. The mechanical experiment results of CIIR nanocomposites showed that the addition of OMMT improved their tensile strength, hardness,and stress relaxation rate. Compared with pure CIIR, when the content of OMMT was 5 phr(part per hundred of rubber), the tensile strength of the nanocomposite was increased by 677% and the elongation at break was also increased by 105.4%. The enhancement of this performance was mainly due to the dispersion of the nanosheets in CIIR rubber and the chemical interaction between the organoclay and the polymer matrix, which was confirmed by morphology and spectral analysis. OMMT also endowed a positive effect on the damping properties of CIIR nanocomposites. After adding 5 phr of OMMT, the nanocomposite owned the best damping performance, and the damping factor, tanδmax, was 37.9% higher than that of pure CIIR. Therefore, the good damping and mechanical properties of these CIIR nanocomposites provided some novel and promising methods for preparing high-damping rubber in a wide temperature range.展开更多
Two nonfoaming bubble separation techniques, air stripping and solvent sublation, are presented and discussed in order to recover butyl acetate (BA) from discharged wastewater after solvent extraction of penicillin. R...Two nonfoaming bubble separation techniques, air stripping and solvent sublation, are presented and discussed in order to recover butyl acetate (BA) from discharged wastewater after solvent extraction of penicillin. Results show air stripping is not suitable for the recovery of BA from the wastewater. Axial concentration of BA had a noted maximum point along the column. In contrast, solvent sublation is very effective to recover BA from the wastewater. In solvent sublation experiments, axial concentration of BA along the column first increased and then decreased from the bottom to the top because of two primary mass transport processes. One is the transport by adsorption or attachment to ascending bubbles, and the other is by dispersion at water-solvent interface and by water film in organic solvent layer. In order to elucidate the high removal efficiency in solvent sublation, the microstructure of the wastewater was studied with optic microscope, which was showed to be an emulsion of BA in water at large concentration of BA. Solvent sublation can be successfully used in the removal of BA from its emulsion in the wastewater. The surface tension of simulated solution composed of lysozyme and BA was studied to understand mutual effect of biological materials and BA. Results show that lysozyme affects the adsorption of BA at air-water interface and they may form a complex between BA and lysozyme molecules.展开更多
Hydrate formation rate and separation effect on the capture of CO2 from binary mixture via forming hydrate with 5 wt% tetra-n-butyl ammonium bromide （TBAB） solution were studied. The results showed that the inductio...Hydrate formation rate and separation effect on the capture of CO2 from binary mixture via forming hydrate with 5 wt% tetra-n-butyl ammonium bromide （TBAB） solution were studied. The results showed that the induction time was 5 min, and the hydrate formation process finished in 1 h at 4.5 ℃ and 4.01 MPa. The hydrate formation rate constant reached the maximum of 1.84× 10^-7 molZ/（s.J） with the feed pressure of 7.30 MPa. The CO2 recovery was about 45 % in the feed pressure range from 4.30 to 7.30 MPa. Under the feed pressure of 4.30 MPa, the maximum separation factor and CO2 concentration in hydrate phase were 7.3 and 38.2 mol%, respectively. The results demonstrated that TBAB accelerated hydrate formation and enriched CO2 in hydrate phase under the gentle condition.展开更多
基金Project(51274255)supported by the National Natural Science Foundation of ChinaProject supported by the Foundation of State Key Laboratory of Comprehensive Utilization of Low-Grade Ores(Zijin Mining Group Co.,Ltd),China
文摘The hydrophobic flocculation of marmatite fines in aqueous suspensions induced by butyl xanthate （KBX） and ammonium dibutyl dithiophosphate （ADD） was investigated using laser particle size analysis, microscopy analysis, electrophoretic light scattering, contact angle measurement and infrared spectroscopy. The studies were performed on single minerals with size 〈20 μm by varying several parameters, including pH, collector concentration and kerosene addition. The results show that the floc fotation closely correlated with the size of flocs and the particle hydrophobicity, but was not lowered with increasing the particle surface charges due to collector adsorption. Under good operating conditions, the floc flotation of marmatite fines as a function of KBX and ADD can all reach floatability over 90%, in comparison with conventional flotation obtaining floatability of about 60%. It also has been found that a small addition of kerosene greatly improved the floc flotation because of the formation of oil films on marmatite particles. The results of FTIR spectra indicate that adsorption of the two collectors onto marmatite were chemical adsorption.
基金financially supported by the National Natural Science Foundation of China(32172131)the Innovative Funds Plan of Henan University of Technology(2020ZKCJ10)the Doctoral Scientific Research Startup Foundation from Henan University of Technology(2021BS016)。
文摘Butyl hydroxyanisole(BHA) is usually blended with other synthetic antioxidants to improve the antioxidative property due to synergistic antioxidation. However, the synergistic antioxidation mechanisms of BHA with synergists have not been revealed yet. Thus, the antioxidation of BHA with butylated hydroxytoluene(BHT), tert-butylhydroquinone(TBHQ), or propyl gallate(PG) was investigated in the 2,2-azobis(2-amidino-propane) dihydrochloride oxidizing system. The contents of BHA, BHT, TBHQ,PG, and transformation products were measured by high-performance liquid chromatography. Transformation products were identified with liquid chromatography-mass spectrometry and gas chromatography–mass spectrometry. Results showed that synergistic antioxidation occurred between BHA and BHT, TBHQ, or PG. The synergistic antioxidation effect of BHA and BHT was attributed to the regeneration of BHA by BHT. Transformation products of BHA and BHT(compounds 6 and 7, dimers of BHA and BHT) had little contribution due to the relatively low content(<0.6%). The synergistic antioxidation effect of BHA and TBHQ or BHA and PG was attributed to the protective mechanism of TBHQ or PG on BHA. No transformation products were detected of BHA and TBHQ. Transformation products of BHA and PG(compounds 9 and 10, dimers of BHA and PG) had limited contribution due to the relatively low percentage(<7%). Therefore, BHA and BHT performed competitive antioxidation,while BHA and TBHQ or PG performed protective antioxidation.
基金Project(51274255)supported by the National Natural Science Foundation of ChinaProject supported by the Co-innovation Center for Clean and Efficient Utilization of Strategic Metal Mineral Resources,China
文摘The effects of galvanic interaction between galena and pyrite on their flotation and electrochemical characters were studied by electrochemical,adsorption,flotation and FTIR techniques,respectively.Electrochemical tests indicate that galena is electrochemically more active than pyrite and serves as an anode in galvanic combination with pyrite.The galvanic current density from a mixture of galena and pyrite is 4 times as high as the self corrosion current density of galena,which indicates that the corrosion rate of galena is accelerated.Adsorption tests show that the adsorption of butyl xanthate on galena surface is enhanced,and affected by a combination of pyrite-galena mixtures and conditioning time.Compared with individual mineral particles,galvanic interaction reduces the floatability difference between galena and pyrite.The flotation recovery of galena decreases while that of pyrite increases when two minerals are mixed together due to the influence of galvanic interaction on the formation of hydrophilic/hydrophobic product.The FTIR results show that the formation of dixanthogen on pyrite surface is depressed due to the galvanic interaction.
文摘Results of oxidation 2-(N-acetylamine)-3-(3,5-di-tert-butyl-4-hydroxyphenyl)-propionic acid oxygen depend on temperature. At 55℃?- 60℃, 2,4-di-tert-butylbicyclo(4,3,1)deca-4,6-dien-8-(N-acetylamine)-3,9-dion-1-oxa is formed. The constitution is based on dates of spectrums 1Н and 13С NMR. At 95℃?- 97℃, mixtures of 2,4-di-tert-butylbicyclo(4,3,1)deca-4,6-dien-8-(N-acetylamine)-3,9-dion-1-oxa and of 6,8-di-tert-butyl-3-(N-acetylamine)spiro(4,5)deca-1-oxa-5,8-dien-2,7-dione are produced. Structures are calculated by the method of Hartrii-Foka. Values of enthalpies and of entropies allow to assume dynamic isomerism.
文摘The catalytic activities of some heteropolyacids(HPAs) in synthesizing butyl acrylate are reported. It has been demonstrated that 12 tungstophosphoric acid is the most effective catalyst among more than 20 HPA(salts). Various factors concerned in this reaction have been investigated. The optimum conditions have been found, that is, the molar ratio of alcohol to acid is 1.2∶1.0 , the catalyst concentration 1%(mass fraction), the reaction time 2 h, the temperature 98—124 ℃ and a certain amount of polymerization inhibitor exists.
文摘[ Objective ] The paper was to study the factors influencing the synthesis of butyl polyglycosides and its synthesis kineties. [ Method ] In the synthesis process of alkyl polyglycosides by transglyeosidation method, p-toluenesulfonie acid and stearie acid were used as composite catalyst, intermediate product butyl polyglycosides was prepared via reactive distillation technology. [ Result ] The suitable preparation conditian of butyl polyglyeasides was as follows： catalyst usage, 1.2 g（ p-toluenesulfoni ：stearie acid = 6：1 ） ; reaction temperature, 110 ℃ ; the ratio of butanol and glucose, 8： 1. The results showed that the larger the molar ratio of butanol and glucose was,the more the butyl monoside content was, and the less the polymerizatian degree of butyl glyeasides was. The catalyst usage and reaction temperature had little influence on the component of butyl polyglyeesides. With the increase of catalyst usage or reaction temperature,the reaction time was shortened dramatically. The kinetic equation for the synthesis of butyl glueeside was finally obtained as follows： -dCA/dt =0.163 7exp（ -1. 968×10^3/RT）CA -0.003 49 exp （ -2.727×10^3/RT） Ce. [ Conclusionl The suitable condition for the preparation of butyl polyglyeasides and its synthesis kinetic equation obtained in the study could provide theoretical basis for the synthesis of long-chain alkyl polyglyeasides.
文摘The vapor-liquid equilibrium of binary mixtures of propyl acetate, butyl acetate and isobutyl acetate with meth- anol has been determined at a constant pressure of 0.6 MPa. Results have been modeled with the Peng-Robinson equation, a traditional cubic equation of state widely employed in chemical industries, as well as with the perturbed-chain statistical associating fluid PC-SAFT theory of Gross-Sadowski. By correlation of the binary inter- action parameters of these equations, the measured vapor-liquid equilibrium data can be accurately predicted. Thus, this work shows that these models are able to represent the experimental data for systems with associating comoounds via hydrogen bonding.
文摘The separation of ternary methanol/methyl butyl ether/1-butylchloride mixtures was investigated, which are the main components of the waste liquid. After preliminary studies on the ternary system, the integrated process of extraction and distillation was put forward to separate the ternary system. The results show that methanol carl be removed from the mixtures by extraction using water as the extracting agent. Through distillation of extract and dried raffinate respectively, methanol, methyl butyl ether and 1-butylchloride can be separated and recovered. In addition, the optimal volume for the extracting agent and effects of reflux ratio on the yield of product were also studied. The optimal volume ratio of the extracting agent to material is 1： 3.5, and the yield of the product increases with the increase of reflux ratio.
基金Supported by the National Natural Science Foundation of China(No.2005038561)Natural Science Foundation of Province,China(Nos.20060571 and 20070406)
文摘A novel macrocyclic complex 2{[（n-Bu2Sn）4O2-L2]2DMF} was synthesized by the reaction of 4-（1,2- dithioethylene）methylene-3,5-disoxo-1,6-heptadiene-1,7-dis-（o-formy~）-dis-p-phenoxyacetic acid（LH2, compound 1） with di-n-butyltin oxide. Compound 1 and complex 2 were characterized by elemental analysis, FTIR spectroscopy, and ~H NMR spectroscopy. The crystal structure of complex 2 was determined by single crystal X-ray diffraction analysis. There are two crystallographic independent molecules in complex 2, and each molecule structure is centro-symmetric and features a central rhombus cyclic Bu4Sn2O2 unit with two exocyclic Sn atoms linked at the O atoms of the four-membered ring. In molecule A, the four Sn atoms are five-coordinated. However, in molecule B, the four Sn atoms have two different coordination geometries, the endocyclic Sn atoms are five-coordinated and the exocyclic Sn atoms are four-coordinated. The dicarboxylate ligands in molecules A and B bridge exocylic or endocyclic tin atoms, forming two macroheterocycles with 26 atoms. Pilot studies have indicated that complex 2 has good anti- bacterial and antitumour activities.
基金supported by the 973 Program (2005CB623607)the National Natural Science Foundation of China (No.20771061)the scientific program 2008BAE64B09
文摘Use of free air as oxidant and copper（II）chloride as catalyst,3,3＇-di-tert-butylbi-phenyl-2,5,2＇,5＇-diquinone（BBDQ）was prepared via catalytic oxidation of 2,2＇-dihydroxy-3,3＇-di-tert-butyl-5,5＇-dimethoxy-biphenyl（di-BHA）.The yield of reaction attained 95% and the selectivity for BBDQ was 100%.The single-crystal X-ray diffraction analysis reveals that the dihedral angle between two rings（benzene rings for di-BHA and quinone rings for BBDQ）changes from 89.8 to 45.3o,indicating the steric hindrance effects of methyl disappear in the oxidation process.The crystal structures of di-BHA and BBDQ are further confirmed by their spectral characterizations.The probable mechanism for this oxidation process is also discussed.
文摘On an example of spontaneous changes 5,7-di-tert-butylspiro (2,5) octa-4,7-diene-6-one at room temperature, a new example of condensations in a solid station is opened. The single crystal of 2-(3’, 5'-di-tert-butyl-4'-hydroxy-phenyl)-ethyloxy-p-cresole is produced as result of a structure transformation 5,7-di-tert-butylspiro (2,5) octa-4,7-diene-6-one in a solid phase at room temperature except a single crystal at transformation 5,7-di-tert-butylspiro (2,5) octa-4,7-diene-6-one a new substance is formed too. Spectrums 1Н and 13С NMR differ from similar spectrums of initial compound and the single crystal. New substance represents an admixture of isomeric compounds, capable reversible to be transformed in initial 5,7-di-tert-butylspiro(2,5) octa-4,7-diene-6-one and 2-(3’, 5'-di-tert-butyl-4'-hydroxyphenyl)-ethyloxy-p-cresole.
基金funded by the Polish Ministry of Science and Higher Education(2004‐2007 project no. 2PO5D2926)
文摘Objective The aim of the present study was to investigate the effects of paternal Di‐N‐butyl‐phthalate （DBP） exposure pre‐ and postnatally on F1 generation offspring,and prenatally on F2 generation offspring.Methods Male mice were exposed to either 500 mg/kg or 2 000 mg/kg of DBP for 8 weeks,and mated with non‐exposed females.Three‐quarters of the females were sacrificed a day prior to parturition,and examined for the number of living and dead implantations,and incidence of gross malformations.Pups from the remaining females were assessed for developmental markers,growth parameters,as well as sperm quantity and quality.Results There were no changes in the fertility of parents and in intrauterine development of the offspring.Pups of DBP‐exposed males demonstrated growth‐retardation.Following paternal exposure to 500 mg/kg bw of DBP,there were almost twice the number of males than females born in the F1 generation.F1 generation females had a 2.5‐day delay in vaginal opening.Paternal exposure to 2 000 mg/kg bw of DBP increased the incidence of sperm head malformations in F1 generation males;however,there were no changes in the fertility and viability of foetuses in the F2 generation.Conclusion Paternal DBP exposure may disturb the sex ratio of the offspring,delay female sexual maturation,and deteriorate the sperm quality of F1 generation males.
基金Supported by Fundamental Research Funds for the Central Universities(2572014EA0703)Innovation Experiment Program for University Students from Northeast Forestry University(201310225108)~~
文摘[Objective] The aim of this study was to detect the acute toxicity of clethodim, cypermethrin and 2,4-D-butylate. [Method] Chironomus sinicus larvae were exposed to different concentrations of clethodim, cypermethrin and 2,4-D-butylate. Survival rate, lethal concentration 50 （LC50） and superoxide dismutase （SOD） activity in the homogenate of the larvae were monitored to detect the toxicity of the pesti- cides. [Result] The survival rates of C. sinicus larvae exposed to cypermethrin and 2,4-D-butylate for 12 h were almost unchanged at different concentrations, but de- creased with concentration increasing 48 h later. For each pesticide, the differences in survival rates of C. sinicus larvae at 48 h were significant. The 48 h LC50 of clethodim, cypermethrin and 2,4-D-butylate to C. sinicus larvae were 1.842, 0.150 and 1.999 mg/L, respectively. The acute toxicity of cypermethrin was the highest a- mong the three pesticides and that of 2,4-D-butylate was the lowest. Clethodim sig- nificantly reduced the SOD content in a dose-dependent manner. 2,4-D-butylate also reduced SOD content in C. sinicus larvae, but the reduction was not significantly re- lated to its dosage. However, cypermethrin showed no significant effect on SOD ac- tivity in C. sinicus larvae.
基金Supported by the National Natural Science Foundation of China （No.20376004）
文摘The catalytic performance of some quaternary ammonium salts for the liquid phase reaction of butanol and hydrochloric acid at different conditions was studied experimentally and compared with the traditional catalyst （ZnCl2）. The organic ammonium catalysts investigated include ionic liquids N-butyl-N-methyl imidazolium fluoborate （[BMIM][BF4]） and N-butyl-N-methylimidazolium chloride （[BMIM]Cl） as well as hydrochloric salts of N-methylimidazol （[HMIM]Cl）, pyridine （[HPy]Cl） and triethylamine （[HEt3N]Cl）. It is shown that the intrinsic catalytic performance of all organic ammonium salts except [HEt3N]Cl is slightly superior to ZnCl2, while the selectivity of butyl chloride is nearly at the same level around 96%. The conversion of butanol increases slightly with temperature and the catalyst amount added while the variation of selectivity is not obvious. Based on the recycle experiments, the ionic liquids as catalyst for the reaction of butanol and hydrochloric acid can be used more than 5 times, which suggests great potential of using ionic liquids as novel catalyst for such reactions.
基金Projects(51504053,51374079)supported by the National Natural Science Foundation of ChinaProject(2015M571324)supported by the Postdoctoral Science Foundation of China
文摘In this paper,the effect of sodium butyl xanthate(NaBX)adsorption on the surface of bornite at different pH on flotation was studied by adsorption kinetic and thermodynamic.The flotation results demonstrated that the recovery was the highest when pH was 9 in NaBX solution(4×10^?5 mol/L).The adsorption kinetics showed the reaction of NaBX on the bornite conformed to the second order kinetic equation;it belonged to the multimolecular layer adsorption of Freundlich model;the maximum adsorption rate constant was 0.30 g/(10^?6 mol·min),and the equilibrium adsorption capacity was 2.70×10^?6 mol/g.Thermodynamic calculation results indicated that the adsorption process was spontaneous chemisorption,and the adsorption products of NaBX on bornite surface were cupric butyl xanthate,ferric butyl xanthate and dixanthogen,which were confirmed by infrared spectrum measurements.
基金supported by the National Natural Science Foun-dation of China(51873103)Capacity Building Project of Some Local Colleges and Universities in Shanghai(17030501200)+2 种基金Scien-tific and Technological Support Projects in the Field of Biomedicine(19441901700)Talent Program of Shanghai University of Engi-neering Science(2017RC422017)First-rate Discipline Con-struction of Applied Chemistry(2018xk-B-06).
文摘Montmorillonite(MMT) was modified by ultrasound and castor oil quaternary ammonium salt intercalation method to prepare a new type of organic montmorillonite(OMMT). The surface structure, particle morphology, interlayer distance, and thermal behavior of the samples obtained were characterized. The modified OMMT was then added to chlorinated butyl rubber(CIIR) by mechanical blending, and a composite material with excellent damping properties was obtained. The mechanical experiment results of CIIR nanocomposites showed that the addition of OMMT improved their tensile strength, hardness,and stress relaxation rate. Compared with pure CIIR, when the content of OMMT was 5 phr(part per hundred of rubber), the tensile strength of the nanocomposite was increased by 677% and the elongation at break was also increased by 105.4%. The enhancement of this performance was mainly due to the dispersion of the nanosheets in CIIR rubber and the chemical interaction between the organoclay and the polymer matrix, which was confirmed by morphology and spectral analysis. OMMT also endowed a positive effect on the damping properties of CIIR nanocomposites. After adding 5 phr of OMMT, the nanocomposite owned the best damping performance, and the damping factor, tanδmax, was 37.9% higher than that of pure CIIR. Therefore, the good damping and mechanical properties of these CIIR nanocomposites provided some novel and promising methods for preparing high-damping rubber in a wide temperature range.
基金Supported by the National Natural Science Foundation of China (No. 20406021, No. 20236050 and No. 20221603).
文摘Two nonfoaming bubble separation techniques, air stripping and solvent sublation, are presented and discussed in order to recover butyl acetate (BA) from discharged wastewater after solvent extraction of penicillin. Results show air stripping is not suitable for the recovery of BA from the wastewater. Axial concentration of BA had a noted maximum point along the column. In contrast, solvent sublation is very effective to recover BA from the wastewater. In solvent sublation experiments, axial concentration of BA along the column first increased and then decreased from the bottom to the top because of two primary mass transport processes. One is the transport by adsorption or attachment to ascending bubbles, and the other is by dispersion at water-solvent interface and by water film in organic solvent layer. In order to elucidate the high removal efficiency in solvent sublation, the microstructure of the wastewater was studied with optic microscope, which was showed to be an emulsion of BA in water at large concentration of BA. Solvent sublation can be successfully used in the removal of BA from its emulsion in the wastewater. The surface tension of simulated solution composed of lysozyme and BA was studied to understand mutual effect of biological materials and BA. Results show that lysozyme affects the adsorption of BA at air-water interface and they may form a complex between BA and lysozyme molecules.
文摘Hydrate formation rate and separation effect on the capture of CO2 from binary mixture via forming hydrate with 5 wt% tetra-n-butyl ammonium bromide （TBAB） solution were studied. The results showed that the induction time was 5 min, and the hydrate formation process finished in 1 h at 4.5 ℃ and 4.01 MPa. The hydrate formation rate constant reached the maximum of 1.84× 10^-7 molZ/（s.J） with the feed pressure of 7.30 MPa. The CO2 recovery was about 45 % in the feed pressure range from 4.30 to 7.30 MPa. Under the feed pressure of 4.30 MPa, the maximum separation factor and CO2 concentration in hydrate phase were 7.3 and 38.2 mol%, respectively. The results demonstrated that TBAB accelerated hydrate formation and enriched CO2 in hydrate phase under the gentle condition.
