The strain No. 2 which was isolated from the soil through enrichment culture was used as the experimental material. It was cultured in liquid medium to research decolorizing effect to Rose Bengal and soluble color pas...The strain No. 2 which was isolated from the soil through enrichment culture was used as the experimental material. It was cultured in liquid medium to research decolorizing effect to Rose Bengal and soluble color paste under the different conditions of different media,carbon sources,nitrogen sources,initial pH values and culture temperatures. The results revealed that the optimum decolorizing conditions were using bean juice medium and PDA medium as the minimal medium,sucrose as the carbon source,and ammonium nitrate as the nitrogen source,initial pH 6.0-8.0. In addition,the strain was primarily identified as Aspergillus flavus according to its morphous and ITS sequence analysis.展开更多
Method for decolrizing dyed wastewater was researched and the affecting factors dicussed. The result shows that the conditions for getting an optimum decolorization effect are: a reaction time of 60 min, a coke size o...Method for decolrizing dyed wastewater was researched and the affecting factors dicussed. The result shows that the conditions for getting an optimum decolorization effect are: a reaction time of 60 min, a coke size of 5～10 mm, a solid/liquid ratio of 1∶10, an air blast volume of 4 m3/h, and proper Fe/coke ratio determined by the type of dye material. The system acidity influences dyed wastewater in different ways, i.e., acid condition is good for the decolorization of scarlet 3R and methyl orange simulated wastewater but bad for that of alkali violet 5BN simulated wastewater, while the decolorization of dispersed yellow E-RGFL simulated wastewater has nothing to do with pH.展开更多
To evaluate decolorization and detoxification of Azure B dye by a newly isolated Bacillus sp. MZS 10 strain, the cultivation medium and decolorization mechanism of the isolate were investigated. The decolorization was...To evaluate decolorization and detoxification of Azure B dye by a newly isolated Bacillus sp. MZS 10 strain, the cultivation medium and decolorization mechanism of the isolate were investigated. The decolorization was discovered to be dependent on cell density of the isolate and reached 93.55% （0.04 g/L） after 14 hr of cultivation in a 5 L stirred-tank fermenter at 2.0 g/L yeast extract and 6.0 g/L soluble starch and a small amount of mineral salts. The decolorization metabolites were identified with ultra performance liquid chromatography-tandem mass spectroscopy （UPLC-MS）. A mechanism for decolorization of Azure B was proposed as follows： the C=N in Azure B was initially reduced to -NH by nicotinamide adenine dinucleotide phosphate （NADPH）-dependent quinone dehydrogenase, and then the -NH further combined with -OH derived from glucose to form a stable and colorless compound through a dehydration reaction. The phytotoxicity was evaluated for both Azure B and its related derivatives produced by Bacillus sp. MZS 10 decolorization, indicating that the decolorization metabolites were less toxic than original dye. The decolorization efficiency and mechanism shown by Bacillus sp. MZS10 provided insight on its potential application for the bioremediation of the dye Azure B.展开更多
The coagulation process is a widely applied technology in water and wastewater treatment.Novel composite polyferric mag-nesium-silicate-sulfate(PFMS)coagulants were synthesized using Na_(2)SiO_(3)·9H_(2)O,Fe_(2)(...The coagulation process is a widely applied technology in water and wastewater treatment.Novel composite polyferric mag-nesium-silicate-sulfate(PFMS)coagulants were synthesized using Na_(2)SiO_(3)·9H_(2)O,Fe_(2)(SO_(4))_(3),and MgSO_(4) as raw materials in this paper.The effects of aging time,Fe:Si:Mg,and OH:M molar ratios(M represents the metal ions)on the coagulation performance of the as-pre-pared PFMS were systematically investigated to obtain optimum coagulants.The results showed that PFMS coagulant exhibited good co-agulation properties in the treatment of simulated humic acid-kaolin surface water and reactive dye wastewater.When the molar ratio was controlled at Fe:Si:Mg=2:2:1 and OH:M=0.32,the obtained PFMS presented excellent stability and a high coagulation efficiency.The removal efficiency of ultraviolet UV254 was 99.81%,and the residual turbidity of the surface water reached 0.56 NTU at a dosage of 30 mg·L^(-1).After standing the coagulant for 120 d in the laboratory,the removal efficiency of UV254 and residual turbidity of the surface wa-ter were 88.12%and 0.68 NTU,respectively,which accord with the surface water treatment requirements.In addition,the coagulation performance in the treatment of reactive dye wastewater was greatly improved by combining the advantages of magnesium and iron salts.Compared with polyferric silicate-sulfate(PFS)and polymagnesium silicate-sulfate(PMS),the PFMS coagulant played a better decolor-ization role within the pH range of 7-13.展开更多
Background:Sapindus mukurossi extract(SME)is a kind of natural surface active ingredient with potential applications in cleansing products.However,the polyphenols and pigments contained in the extract may cause color ...Background:Sapindus mukurossi extract(SME)is a kind of natural surface active ingredient with potential applications in cleansing products.However,the polyphenols and pigments contained in the extract may cause color browning of the products during storage especially at elevated temperatures,affecting its high level addition in the products.Objective:To explore a decolorization process suitable for industrialization realize the high level addition of SME and explore the potential of SME in the field of controlling sebum esters.Materials and Methods:SME was prepared by adsorbing polyphenols on the D301 resin and oxidation decoloring oxidation.Investigated its sebum-control efficacy by SZ95 model and clinical study.Results:The results demonstrate that the D301 resin displays the best adsorption selectivity for polyphenols in SME,and the polyphenol adsorption ratio of D301 resin(5 wt%)can reach 83.6%;The optimal decolorization conditions are pH=7.8,temperature 73℃and decolorization time 5.7 h when H2O2 content is 6%,The prepared SME shows no obvious changes in color and retain stable during the high temperature(50℃)test period of 28 days.4μg/mL of SME decreases the lipid synthesis of SZ95 cells by 24.8%.The clinic efficacy of the shampoo containing 10%SME(by dry extract weigh)is further evaluated.No significant changes in the skin moisture content and transepidermal water loss(TEWL)are observed within four weeks after using the product,while the scalp sebum level is significantly reduced.Conclusion:In this study,we prepared a light-colored,highly stable SME,enabled its high-level addition in cleansing and care products and found its sebum-control efficacy.展开更多
Porous silver-modified ZnO microrods photocatalysts were synthesized through direct thermal decomposition of the Ag-doped zinctartrate precursor,which was prepared by homogeneous precipitation method at 80 °C for...Porous silver-modified ZnO microrods photocatalysts were synthesized through direct thermal decomposition of the Ag-doped zinctartrate precursor,which was prepared by homogeneous precipitation method at 80 °C for 2 h.The obtained samples were characterized by XRD,FTIR,TG？DTA and UV-VIS absorption spectroscopy.The photocatalytic activity of the as-prepared porous Ag/ZnO microrods was tested with the photocatalytic degradation of methyl orange.The results indicate that doping Ag greatly improves the photocatalytic efficiency of ZnO and 3% Ag-doped（mole fraction） ZnO porous microrod photocatalyst exhibits the highest photocatalytic decolorization efficiency,leading to as much as 80% reduction of MO concentration in 120 min.Moreover,the 3% Ag-doped porous microrods also possess higher photocatalytic activity under the real sunlight irradiation.展开更多
[Objective] To screen out a microbial flocculant with good decolorization effect on methyl orange wastewater,and study the effect of different cultural conditions on decolorization effect of methyl orange.[Method] Abs...[Objective] To screen out a microbial flocculant with good decolorization effect on methyl orange wastewater,and study the effect of different cultural conditions on decolorization effect of methyl orange.[Method] Absorbance of methyl orange solution before and after decolorization was determined by spectrophotometer,and the decolorization rate was calculated to compare the effects of different cultural conditions on removal rate of methyl orange.[Result]An optimal actinomycete stain（F-1-2） was screened out,and the best cultural condition was as follows：with sucrose as carbon source and NaNO3 as nitrogen source,cultured in constant temperature oscillator at 150 r/min,30℃ for 72 h.Under the optimal condition,the removal rate against methyl orange could reach 68.4%.[Conclusion]Different culture conditions have great impact on decolorization effect of strain.展开更多
A crystalline sapphire （Al2O3） boule （Ф10 × 80mm^3） grown by the temperature gradient technique （TGT） is a bit colored due to carbon volatilization from the graphite heater at high temperatures and the abs...A crystalline sapphire （Al2O3） boule （Ф10 × 80mm^3） grown by the temperature gradient technique （TGT） is a bit colored due to carbon volatilization from the graphite heater at high temperatures and the absorption of transitional metal inclusions in the raw material. The sapphire becomes colorless and transparent after decolorization and decarbonization in successive annealings in air and hydrogen at high temperatures. The quality, optical transmissivity,and homogeneity of the sapphire are remarkably improved.展开更多
A coagulation/flocculation process using the composite flocculant polyaluminum chloride-epichlorohydrin dimethylamine （PAC- EPI-DMA） was employed for the treatment of an anionic azo dye （Reactive Brilliant Red K-2B...A coagulation/flocculation process using the composite flocculant polyaluminum chloride-epichlorohydrin dimethylamine （PAC- EPI-DMA） was employed for the treatment of an anionic azo dye （Reactive Brilliant Red K-2BP dye）. The effect of viscosity 01）, basicity （B = [OH]/[Al]） and organic content （Wp） on the flocculation performance as well as the mechanism of PAC-EPI-DMA flocculant were investigated. The η was the key factor affecting the dye removal efficiency of PAC-EPI-DMA. PAC-EPI-DMA with an intermediate η （2400 mPa.sec） gave higher decolorization efficiency by adsorption bridging and charge neutralization due to the co-effect of PAC and EPI-DMA polymers. The Wp of the composite flocculant was a minor important factor for the flocculation. The adsorption bridging of PAC-EPI-DMA with η of 300 or 4300 mPa.sec played an important role with the increase of Wp, whereas the charge neutralization of them was weaker with the increase of Wp. There was interaction between Wp and B on the removal of reactive dye. The composite flocculant with intermediate viscosity and organic content was effective for the treatment of reactive dyeing wastewater, which could achieve high reactive dye removal efficiency with low organic dosage.展开更多
To achieve effective decolorization of reactive dyes,laccase immobilization was investigated.Laccase 0.2%(m/V)(Denilite IIS) was trapped in beads of alginate/gelatin blent with polyethylene glycol(PEG),and then the su...To achieve effective decolorization of reactive dyes,laccase immobilization was investigated.Laccase 0.2%(m/V)(Denilite IIS) was trapped in beads of alginate/gelatin blent with polyethylene glycol(PEG),and then the supporters were activated by cross-linking with glutaraldehyde.The results of repeated batch decolorization showed that gelatin and appropriate concentration of glutaraldehyde accelerated the decolorization of Reactive Red B-3BF(RRB);PEG had a positive effect on enzyme stability and led to an inc...展开更多
Green macroalga Caulerpa lentillifera was found to have reasonable adsorption capacity for basic dyes, Astrazon Blue FGRL （AB）, Astrazon Red GTLN （AR）, and Astrazon Golden Yellow GL-E （AY）. The initial dye conce...Green macroalga Caulerpa lentillifera was found to have reasonable adsorption capacity for basic dyes, Astrazon Blue FGRL （AB）, Astrazon Red GTLN （AR）, and Astrazon Golden Yellow GL-E （AY）. The initial dye concentration was in the range of 100-1,800 mg/L. The dried algal sorbent was ground and sieved into 3 sizes： S （0.1-0.84 mm）, M （0.84-2.0 mm）, and L sizes （larger than 2.0 mm）. For all conditions examined in this work （at 25℃ in batch systems）, the adsorption reached equilibrium within the first hour. The kinetic data corresponded well with the pseudo second order kinetic model where the rate constant, k2, decreased as the sorbent size increased for all dyes. The adsorption isotherms followed both Langmuir and Freundlich models. Among three sorbent sizes, S size gave the highest adsorption capacity followed by M and L sizes. A reduction of sorbent size increased the specific surface area for mass transfer, and also increased the total pore volume, thus providing more active sites for adsorption. The adsorption of AB was adversely influenced by the protonation of algal surface at low pH. On the other hand, the adsorption of AR and AY could be due to weak electrostatic interaction, which was not significantly affected by pH. Increasing salinity of the system caused a decrease in adsorption capacity possibly due to the competition between Na^＋ and the dye cations for the binding sites on algal surface. Moreover, an increase in salinity generated a compressed electrical double layer on the algal surface which exerted repulsive force, retarding the adsorption of positive charged molecules such as the basic dyes.展开更多
Pseudomonas otitidis WL-13, which has a high capacity to decolorize triphenylmethane dyes, was isolated from activated sludge obtained from a wastewater treatment plant of a dyeing industry. This strain exhibited a re...Pseudomonas otitidis WL-13, which has a high capacity to decolorize triphenylmethane dyes, was isolated from activated sludge obtained from a wastewater treatment plant of a dyeing industry. This strain exhibited a remarkable color-removal capability when tested against several triphenylmethane dyes under both shaking and static conditions at high concentrations of dyes. More than 95% of Malachite Green and Brilliant Green was removed within 12 h at 500 μmol/L dye concentration under shaking conditions. Crystal Violet lost about 13% of its color under the same conditions tested. The rate of decolorization increased when the M9 medium was supplemented with yeast extract. The optimum pH and temperature for color removal were 7-9 and 35-40℃, respectively. The observed changes in the visible spectra and the inspection of bacterial growth indicated the color-removal by the adsorption of dye to the cells during incubation with strains.展开更多
Some problems including low treatment capacity,agglomeration and clogging phenomena,and short working life,limit the application of pre-treatment methods involving zero-valent iron （ZVI）.In this article,ZVI was froz...Some problems including low treatment capacity,agglomeration and clogging phenomena,and short working life,limit the application of pre-treatment methods involving zero-valent iron （ZVI）.In this article,ZVI was frozen in an amorphous state through a melt-spinning technique,and the decolorization effect of amorphous ZVI on Acid Orange II solution was investigated under varied conditions of experimental variables such as reaction temperature,ribbon dosage,and initial pH.Batch experiments suggested that the decolorization rate was enhanced with the increase of reaction temperature and ribbon dosage,but decreased with increasing initial solution pH.Kinetic analyses indicated that the decolorization process followed a first order exponential kinetic model,and the surface-normalized decolorization rate could reach 2.09 L/（m^2 ·min） at room temperature,which was about ten times larger than any previously reported under similar conditions.Recycling experiments also proved that the ribbons could be reused at least four times without obvious decay of decolorization rate and efficiency.This study suggests a tremendous application potential for amorphous ZVI in remediation of groundwater or wastewater contaminated with azo dyes.展开更多
The effects of chloride anion （Cl-） （up to 1.0 mol/L） on the decolorization of a model compound,azo dye Acid Orange 7 （AO7）,by sulfate radical （SO4-） based-peroxydisulfate （PS） or peroxymonosulfate （PMS） o...The effects of chloride anion （Cl-） （up to 1.0 mol/L） on the decolorization of a model compound,azo dye Acid Orange 7 （AO7）,by sulfate radical （SO4-） based-peroxydisulfate （PS） or peroxymonosulfate （PMS） oxidation under various activated conditions （UV 254 nm /PS,Thermal （70°C/PS,UV 254 nm /PMS,Co 2＋ /PMS） were investigated.Methanol and NH4 ＋ were used as quenching reagents to determine the contributions of active chlorine species （dichloride radical （Cl2-.） and hypochlorous acid （HClO））.The results indicated that the effects of Cl- on the reaction mechanism were different under various activated conditions.For UV/PS and Thermal/PS,the inhibition tendency became more clear as the Cl- concentration increased,probably due to the reaction between Cl- and SO4-.and the generation of Cl2-.or HClO.For UV/PMS,Cl- did not exhibit inhibition when the concentration was below 0.1 mol/L.As Cl- concentration reached to 1.0 mol/L,the decolorization rate of AO7 was,however,accelerated,possibly because PMS directly reacts with Cl- to form HClO.For Co2＋ /PMS,Cl- exhibited a significant inhibiting effect even at low concentration （ 0.01 mol/L）.When Cl- concentration exceeded 0.1 mol/L,the activation of PMS by Co 2＋ was almost completely inhibited.Under this condition,HClO maybe played a major role in decolorization of AO7.The results implicated that chloride ion is an important factor in SO4-.-based degradation of organic contamination in chloride-containing water.展开更多
In order to improve the efficient decolorization of dye-containing water by biosorbent and understand the biosorption mechanism, the self-immobilization mycelial pellets were prepared using a marine-derived fungus Asp...In order to improve the efficient decolorization of dye-containing water by biosorbent and understand the biosorption mechanism, the self-immobilization mycelial pellets were prepared using a marine-derived fungus Aspergillus niger ZJUBE-1, and an azo dye, Congo red was chosen as a model dye to investigate batch decolorization efficiency by pellets. The pellets as biosorbent showed strong salt and acid tolerance in biosorption process. The results for dye adsorption showed that the biosorption process fitted well with models of pseudo-second-order kinetic and Langmuir isotherm, with a maximum adsorption capacity of 263.2 mg·g^(-1) mycelium. During 6 batches of continuous decolorization operation, the mycelial pellets could possess efficient decolorization abilities(>98.5%).The appearance of new peak in the UV–Vis spectral result indicated that the decolorization process may also contain biodegradation. The mechanism studies showed that efficient biosorption ability of pellets only relies on the active zone on the surface of the pellet, which can be enhanced by nutrition supplement or be shifted outward by a reculture process.展开更多
A strain of photosynthetic bacterium, Rhodopseudomonas palustris W1, isolated from a lab-scale anaerobic moving bed biofilm reactor (MBBR) treating textile e?uent was demonstrated to decolorize Reactive Black 5 (RB5) ...A strain of photosynthetic bacterium, Rhodopseudomonas palustris W1, isolated from a lab-scale anaerobic moving bed biofilm reactor (MBBR) treating textile e?uent was demonstrated to decolorize Reactive Black 5 (RB5) effciently under anaerobic condition. By a series of batch tests, the suitable conditions for RB5 decolorization were obtained, namely, pH < 10, light presence, glutamine or lactate as carbon source with concentration more than 500 mg/L when lactate is selected, NH4Cl as a nitrogen source wi...展开更多
The capability of decolorization for commercial dyes by Coriolus versicolor fermentation broth containing laccase with or without immobilized mycelium was evaluated. With cell free fermentation broth containing l...The capability of decolorization for commercial dyes by Coriolus versicolor fermentation broth containing laccase with or without immobilized mycelium was evaluated. With cell free fermentation broth containing laccase, high decolorization ratio was achieved for acid orange 7, but not for the other dyes concerned. The immobilized mycelium was proved to be more efficient than the cell free system. All the four dyestuffs studied were found being decolourized with certain extent by immobilized mycelium. The repeated batch decolorization was carried out with satisfactory results. The experimental data showed that the continuous decolorization of wastewater from a printing and dyeing industry was possible by using the self immobilized C. Versicolor.展开更多
Quantitative structure-biodegradability relationships （QSBRs） were established to develop predictive models and mechanistic explanations for acid dyestuffs as well as biological activities. With a total of four desc...Quantitative structure-biodegradability relationships （QSBRs） were established to develop predictive models and mechanistic explanations for acid dyestuffs as well as biological activities. With a total of four descriptors, molecular weight （MW）, energies of the highest occupied molecular orbital （EHOMO）, the lowest unoccupied molecular orbital （ELUMO）, and the excited state （EES）, calculated using quantum chemical semi-empirical methodology, a series of models were analyzed between the dye biodegradability and each descriptor. Results showed that EHOMO and Mw were the dominant parameters controlling the biodegradability of acid dyes. A statistically robust QSBR model was developed for all studied dyes, with the combined application of EHOMO and Mw. The calculated biodegradations fitted well with the experimental data monitored in a facultative-aerobic process, indicative of the reliable prediction and mechanistic character of the developed model.展开更多
The pulsed high-voltage discharge is a new advanced oxidation technology for water treatment. Methyl Orange （MO） dye wastewater was chosen as the target object. Some investigations were conducted on MO decoloration ...The pulsed high-voltage discharge is a new advanced oxidation technology for water treatment. Methyl Orange （MO） dye wastewater was chosen as the target object. Some investigations were conducted on MO decoloration including the discharge characteristics of the multi-needle reactor, parameter optimization, and the degradation mechanism. The following results were obtained. The color group of the azo dye MO was effectively decomposed by water surface plasma. The decoloration rate was promoted with the increase of treatment time, peak voltage, and pulse frequency. When the initial conductivity was 1700 μS/cm, the decoloration rate was the highest. The optimum distance between the needle electrodes and the water surface was 1 mm, the distance between the grounding electrode and the water surface was 28 mm, and the number of needle electrodes and spacing between needles were 24 and 7.5 mm, respectively. The decoloration rate of MO was affected by the gas in the reactor and varied in the order oxygen 〉 air〉 argon 〉 nitrogen, and the energy yield obtained in this investigation was 0.45 g/kWh.展开更多
The Electro-chemistry process to produce Fenton reagents has been described. The in situ oxidation of dyes, acid chrome and alizarin red(Fenton reagents) with electrogenerated hydroxyl radicals was investigated. The \...The Electro-chemistry process to produce Fenton reagents has been described. The in situ oxidation of dyes, acid chrome and alizarin red(Fenton reagents) with electrogenerated hydroxyl radicals was investigated. The \{ I-V \} cyclic voltammograms were measured. The redox peaks of the dyes were not observed in the treated dye solutions instead of a couple of O_2/H_2O_2 redox peaks. The IR results indicate that acid chrome dye was decomposed into naphthylamine and phenol aminophenol sulfonic acid. The degradation and the decolorization of the dyes were comfirmed by the visible spectrum and the chemical analysis. The COD_ cr removing rate was close to 80%.展开更多
基金Supported by National Science &Technology Pillar Program in the Eleventh Five-year Plan Period ( NO. 2008BADC4B08 )International Science and Technology Cooperation Project of Ministry of Science and Technology of China (NO. 2010DFA62510)Post-graduate Innovation Fund (NO. 54040108003)~~
文摘The strain No. 2 which was isolated from the soil through enrichment culture was used as the experimental material. It was cultured in liquid medium to research decolorizing effect to Rose Bengal and soluble color paste under the different conditions of different media,carbon sources,nitrogen sources,initial pH values and culture temperatures. The results revealed that the optimum decolorizing conditions were using bean juice medium and PDA medium as the minimal medium,sucrose as the carbon source,and ammonium nitrate as the nitrogen source,initial pH 6.0-8.0. In addition,the strain was primarily identified as Aspergillus flavus according to its morphous and ITS sequence analysis.
文摘Method for decolrizing dyed wastewater was researched and the affecting factors dicussed. The result shows that the conditions for getting an optimum decolorization effect are: a reaction time of 60 min, a coke size of 5～10 mm, a solid/liquid ratio of 1∶10, an air blast volume of 4 m3/h, and proper Fe/coke ratio determined by the type of dye material. The system acidity influences dyed wastewater in different ways, i.e., acid condition is good for the decolorization of scarlet 3R and methyl orange simulated wastewater but bad for that of alkali violet 5BN simulated wastewater, while the decolorization of dispersed yellow E-RGFL simulated wastewater has nothing to do with pH.
基金supported by the Science&Technology Program of Jiangsu Province(No.BE2011623)the Scientific Research Project of Provincial Environmental Protection Bureau of Jiangsu Province(No.2012047)
文摘To evaluate decolorization and detoxification of Azure B dye by a newly isolated Bacillus sp. MZS 10 strain, the cultivation medium and decolorization mechanism of the isolate were investigated. The decolorization was discovered to be dependent on cell density of the isolate and reached 93.55% （0.04 g/L） after 14 hr of cultivation in a 5 L stirred-tank fermenter at 2.0 g/L yeast extract and 6.0 g/L soluble starch and a small amount of mineral salts. The decolorization metabolites were identified with ultra performance liquid chromatography-tandem mass spectroscopy （UPLC-MS）. A mechanism for decolorization of Azure B was proposed as follows： the C=N in Azure B was initially reduced to -NH by nicotinamide adenine dinucleotide phosphate （NADPH）-dependent quinone dehydrogenase, and then the -NH further combined with -OH derived from glucose to form a stable and colorless compound through a dehydration reaction. The phytotoxicity was evaluated for both Azure B and its related derivatives produced by Bacillus sp. MZS 10 decolorization, indicating that the decolorization metabolites were less toxic than original dye. The decolorization efficiency and mechanism shown by Bacillus sp. MZS10 provided insight on its potential application for the bioremediation of the dye Azure B.
基金supported by the National Natural Science Foundation of China (No.U1810205).
文摘The coagulation process is a widely applied technology in water and wastewater treatment.Novel composite polyferric mag-nesium-silicate-sulfate(PFMS)coagulants were synthesized using Na_(2)SiO_(3)·9H_(2)O,Fe_(2)(SO_(4))_(3),and MgSO_(4) as raw materials in this paper.The effects of aging time,Fe:Si:Mg,and OH:M molar ratios(M represents the metal ions)on the coagulation performance of the as-pre-pared PFMS were systematically investigated to obtain optimum coagulants.The results showed that PFMS coagulant exhibited good co-agulation properties in the treatment of simulated humic acid-kaolin surface water and reactive dye wastewater.When the molar ratio was controlled at Fe:Si:Mg=2:2:1 and OH:M=0.32,the obtained PFMS presented excellent stability and a high coagulation efficiency.The removal efficiency of ultraviolet UV254 was 99.81%,and the residual turbidity of the surface water reached 0.56 NTU at a dosage of 30 mg·L^(-1).After standing the coagulant for 120 d in the laboratory,the removal efficiency of UV254 and residual turbidity of the surface wa-ter were 88.12%and 0.68 NTU,respectively,which accord with the surface water treatment requirements.In addition,the coagulation performance in the treatment of reactive dye wastewater was greatly improved by combining the advantages of magnesium and iron salts.Compared with polyferric silicate-sulfate(PFS)and polymagnesium silicate-sulfate(PMS),the PFMS coagulant played a better decolor-ization role within the pH range of 7-13.
文摘Background:Sapindus mukurossi extract(SME)is a kind of natural surface active ingredient with potential applications in cleansing products.However,the polyphenols and pigments contained in the extract may cause color browning of the products during storage especially at elevated temperatures,affecting its high level addition in the products.Objective:To explore a decolorization process suitable for industrialization realize the high level addition of SME and explore the potential of SME in the field of controlling sebum esters.Materials and Methods:SME was prepared by adsorbing polyphenols on the D301 resin and oxidation decoloring oxidation.Investigated its sebum-control efficacy by SZ95 model and clinical study.Results:The results demonstrate that the D301 resin displays the best adsorption selectivity for polyphenols in SME,and the polyphenol adsorption ratio of D301 resin(5 wt%)can reach 83.6%;The optimal decolorization conditions are pH=7.8,temperature 73℃and decolorization time 5.7 h when H2O2 content is 6%,The prepared SME shows no obvious changes in color and retain stable during the high temperature(50℃)test period of 28 days.4μg/mL of SME decreases the lipid synthesis of SZ95 cells by 24.8%.The clinic efficacy of the shampoo containing 10%SME(by dry extract weigh)is further evaluated.No significant changes in the skin moisture content and transepidermal water loss(TEWL)are observed within four weeks after using the product,while the scalp sebum level is significantly reduced.Conclusion:In this study,we prepared a light-colored,highly stable SME,enabled its high-level addition in cleansing and care products and found its sebum-control efficacy.
基金Project (20907001) supported by the National Natural Science Foundation of ChinaProject (KJ2010A336) supported by the University Natural Science Research Project of Anhui Province,ChinaProject (KJ2009A010Z) supported by the Educational Commission of Anhui Province,China
文摘Porous silver-modified ZnO microrods photocatalysts were synthesized through direct thermal decomposition of the Ag-doped zinctartrate precursor,which was prepared by homogeneous precipitation method at 80 °C for 2 h.The obtained samples were characterized by XRD,FTIR,TG？DTA and UV-VIS absorption spectroscopy.The photocatalytic activity of the as-prepared porous Ag/ZnO microrods was tested with the photocatalytic degradation of methyl orange.The results indicate that doping Ag greatly improves the photocatalytic efficiency of ZnO and 3% Ag-doped（mole fraction） ZnO porous microrod photocatalyst exhibits the highest photocatalytic decolorization efficiency,leading to as much as 80% reduction of MO concentration in 120 min.Moreover,the 3% Ag-doped porous microrods also possess higher photocatalytic activity under the real sunlight irradiation.
基金Supported by National Natural Science Foundation of China(51064011)Jiangxi Education Science " Twelfth Five-year" Planning Program (10YB335)Science Foundation for Youths of Jiangxi Educational Committee (GJJ09599)~~
文摘[Objective] To screen out a microbial flocculant with good decolorization effect on methyl orange wastewater,and study the effect of different cultural conditions on decolorization effect of methyl orange.[Method] Absorbance of methyl orange solution before and after decolorization was determined by spectrophotometer,and the decolorization rate was calculated to compare the effects of different cultural conditions on removal rate of methyl orange.[Result]An optimal actinomycete stain（F-1-2） was screened out,and the best cultural condition was as follows：with sucrose as carbon source and NaNO3 as nitrogen source,cultured in constant temperature oscillator at 150 r/min,30℃ for 72 h.Under the optimal condition,the removal rate against methyl orange could reach 68.4%.[Conclusion]Different culture conditions have great impact on decolorization effect of strain.
文摘A crystalline sapphire （Al2O3） boule （Ф10 × 80mm^3） grown by the temperature gradient technique （TGT） is a bit colored due to carbon volatilization from the graphite heater at high temperatures and the absorption of transitional metal inclusions in the raw material. The sapphire becomes colorless and transparent after decolorization and decarbonization in successive annealings in air and hydrogen at high temperatures. The quality, optical transmissivity,and homogeneity of the sapphire are remarkably improved.
基金supported by the National Natural Science Foundation of China (No. 50578089,21077066)the Key Projects in the National Science & Technology Pillar Program in the Eleventh Five-year Plan Period (No. 2006BAJ08B05-2)+2 种基金the Scientific Technology Research and Development Program of Shandong of China (No. 2009GG10006003 2010GZX20605)the Natural Science Foundation of Shandong Province of China (No. ZR2010BM014)
文摘A coagulation/flocculation process using the composite flocculant polyaluminum chloride-epichlorohydrin dimethylamine （PAC- EPI-DMA） was employed for the treatment of an anionic azo dye （Reactive Brilliant Red K-2BP dye）. The effect of viscosity 01）, basicity （B = [OH]/[Al]） and organic content （Wp） on the flocculation performance as well as the mechanism of PAC-EPI-DMA flocculant were investigated. The η was the key factor affecting the dye removal efficiency of PAC-EPI-DMA. PAC-EPI-DMA with an intermediate η （2400 mPa.sec） gave higher decolorization efficiency by adsorption bridging and charge neutralization due to the co-effect of PAC and EPI-DMA polymers. The Wp of the composite flocculant was a minor important factor for the flocculation. The adsorption bridging of PAC-EPI-DMA with η of 300 or 4300 mPa.sec played an important role with the increase of Wp, whereas the charge neutralization of them was weaker with the increase of Wp. There was interaction between Wp and B on the removal of reactive dye. The composite flocculant with intermediate viscosity and organic content was effective for the treatment of reactive dyeing wastewater, which could achieve high reactive dye removal efficiency with low organic dosage.
基金supported by the National Hi-Tech Research and Development Program(863)of China(No.2007AA02Z218)the Open Project Program of Key Lab-oratory of Eco-Textiles,Jiangnan University,Ministry of Education,China(No.KLET0625) the Youth Fundof Jiangnan University(No.2006LQN002).
文摘To achieve effective decolorization of reactive dyes,laccase immobilization was investigated.Laccase 0.2%(m/V)(Denilite IIS) was trapped in beads of alginate/gelatin blent with polyethylene glycol(PEG),and then the supporters were activated by cross-linking with glutaraldehyde.The results of repeated batch decolorization showed that gelatin and appropriate concentration of glutaraldehyde accelerated the decolorization of Reactive Red B-3BF(RRB);PEG had a positive effect on enzyme stability and led to an inc...
文摘Green macroalga Caulerpa lentillifera was found to have reasonable adsorption capacity for basic dyes, Astrazon Blue FGRL （AB）, Astrazon Red GTLN （AR）, and Astrazon Golden Yellow GL-E （AY）. The initial dye concentration was in the range of 100-1,800 mg/L. The dried algal sorbent was ground and sieved into 3 sizes： S （0.1-0.84 mm）, M （0.84-2.0 mm）, and L sizes （larger than 2.0 mm）. For all conditions examined in this work （at 25℃ in batch systems）, the adsorption reached equilibrium within the first hour. The kinetic data corresponded well with the pseudo second order kinetic model where the rate constant, k2, decreased as the sorbent size increased for all dyes. The adsorption isotherms followed both Langmuir and Freundlich models. Among three sorbent sizes, S size gave the highest adsorption capacity followed by M and L sizes. A reduction of sorbent size increased the specific surface area for mass transfer, and also increased the total pore volume, thus providing more active sites for adsorption. The adsorption of AB was adversely influenced by the protonation of algal surface at low pH. On the other hand, the adsorption of AR and AY could be due to weak electrostatic interaction, which was not significantly affected by pH. Increasing salinity of the system caused a decrease in adsorption capacity possibly due to the competition between Na^＋ and the dye cations for the binding sites on algal surface. Moreover, an increase in salinity generated a compressed electrical double layer on the algal surface which exerted repulsive force, retarding the adsorption of positive charged molecules such as the basic dyes.
基金supported by the Dong-A University Research Fund in 2007
文摘Pseudomonas otitidis WL-13, which has a high capacity to decolorize triphenylmethane dyes, was isolated from activated sludge obtained from a wastewater treatment plant of a dyeing industry. This strain exhibited a remarkable color-removal capability when tested against several triphenylmethane dyes under both shaking and static conditions at high concentrations of dyes. More than 95% of Malachite Green and Brilliant Green was removed within 12 h at 500 μmol/L dye concentration under shaking conditions. Crystal Violet lost about 13% of its color under the same conditions tested. The rate of decolorization increased when the M9 medium was supplemented with yeast extract. The optimum pH and temperature for color removal were 7-9 and 35-40℃, respectively. The observed changes in the visible spectra and the inspection of bacterial growth indicated the color-removal by the adsorption of dye to the cells during incubation with strains.
基金the financial support from the Ministry of Science and Technology of China(No. 2011CB606301)the National Natural Science Foundation of China (No. 50825402,51101156)
文摘Some problems including low treatment capacity,agglomeration and clogging phenomena,and short working life,limit the application of pre-treatment methods involving zero-valent iron （ZVI）.In this article,ZVI was frozen in an amorphous state through a melt-spinning technique,and the decolorization effect of amorphous ZVI on Acid Orange II solution was investigated under varied conditions of experimental variables such as reaction temperature,ribbon dosage,and initial pH.Batch experiments suggested that the decolorization rate was enhanced with the increase of reaction temperature and ribbon dosage,but decreased with increasing initial solution pH.Kinetic analyses indicated that the decolorization process followed a first order exponential kinetic model,and the surface-normalized decolorization rate could reach 2.09 L/（m^2 ·min） at room temperature,which was about ten times larger than any previously reported under similar conditions.Recycling experiments also proved that the ribbons could be reused at least four times without obvious decay of decolorization rate and efficiency.This study suggests a tremendous application potential for amorphous ZVI in remediation of groundwater or wastewater contaminated with azo dyes.
基金supported by the National Natural Science Foundation of China (No. 21107101)the Fundamental Research Funds for the Central Universities of China (Ocean University of China)(No.201113005)
文摘The effects of chloride anion （Cl-） （up to 1.0 mol/L） on the decolorization of a model compound,azo dye Acid Orange 7 （AO7）,by sulfate radical （SO4-） based-peroxydisulfate （PS） or peroxymonosulfate （PMS） oxidation under various activated conditions （UV 254 nm /PS,Thermal （70°C/PS,UV 254 nm /PMS,Co 2＋ /PMS） were investigated.Methanol and NH4 ＋ were used as quenching reagents to determine the contributions of active chlorine species （dichloride radical （Cl2-.） and hypochlorous acid （HClO））.The results indicated that the effects of Cl- on the reaction mechanism were different under various activated conditions.For UV/PS and Thermal/PS,the inhibition tendency became more clear as the Cl- concentration increased,probably due to the reaction between Cl- and SO4-.and the generation of Cl2-.or HClO.For UV/PMS,Cl- did not exhibit inhibition when the concentration was below 0.1 mol/L.As Cl- concentration reached to 1.0 mol/L,the decolorization rate of AO7 was,however,accelerated,possibly because PMS directly reacts with Cl- to form HClO.For Co2＋ /PMS,Cl- exhibited a significant inhibiting effect even at low concentration （ 0.01 mol/L）.When Cl- concentration exceeded 0.1 mol/L,the activation of PMS by Co 2＋ was almost completely inhibited.Under this condition,HClO maybe played a major role in decolorization of AO7.The results implicated that chloride ion is an important factor in SO4-.-based degradation of organic contamination in chloride-containing water.
基金Supported by the National Natural Science Foundation of China(No.21376214)
文摘In order to improve the efficient decolorization of dye-containing water by biosorbent and understand the biosorption mechanism, the self-immobilization mycelial pellets were prepared using a marine-derived fungus Aspergillus niger ZJUBE-1, and an azo dye, Congo red was chosen as a model dye to investigate batch decolorization efficiency by pellets. The pellets as biosorbent showed strong salt and acid tolerance in biosorption process. The results for dye adsorption showed that the biosorption process fitted well with models of pseudo-second-order kinetic and Langmuir isotherm, with a maximum adsorption capacity of 263.2 mg·g^(-1) mycelium. During 6 batches of continuous decolorization operation, the mycelial pellets could possess efficient decolorization abilities(>98.5%).The appearance of new peak in the UV–Vis spectral result indicated that the decolorization process may also contain biodegradation. The mechanism studies showed that efficient biosorption ability of pellets only relies on the active zone on the surface of the pellet, which can be enhanced by nutrition supplement or be shifted outward by a reculture process.
基金the Hi-Tech Research and Development Program (863) of China (No.2007AA06Z300)
文摘A strain of photosynthetic bacterium, Rhodopseudomonas palustris W1, isolated from a lab-scale anaerobic moving bed biofilm reactor (MBBR) treating textile e?uent was demonstrated to decolorize Reactive Black 5 (RB5) effciently under anaerobic condition. By a series of batch tests, the suitable conditions for RB5 decolorization were obtained, namely, pH < 10, light presence, glutamine or lactate as carbon source with concentration more than 500 mg/L when lactate is selected, NH4Cl as a nitrogen source wi...
基金TheNationalNaturalScienceFoundationofChina (No .2 9976 0 38)
文摘The capability of decolorization for commercial dyes by Coriolus versicolor fermentation broth containing laccase with or without immobilized mycelium was evaluated. With cell free fermentation broth containing laccase, high decolorization ratio was achieved for acid orange 7, but not for the other dyes concerned. The immobilized mycelium was proved to be more efficient than the cell free system. All the four dyestuffs studied were found being decolourized with certain extent by immobilized mycelium. The repeated batch decolorization was carried out with satisfactory results. The experimental data showed that the continuous decolorization of wastewater from a printing and dyeing industry was possible by using the self immobilized C. Versicolor.
基金Project supported by the Natural Science Foundation of Shanghai, China(No. 06ZR14002).
文摘Quantitative structure-biodegradability relationships （QSBRs） were established to develop predictive models and mechanistic explanations for acid dyestuffs as well as biological activities. With a total of four descriptors, molecular weight （MW）, energies of the highest occupied molecular orbital （EHOMO）, the lowest unoccupied molecular orbital （ELUMO）, and the excited state （EES）, calculated using quantum chemical semi-empirical methodology, a series of models were analyzed between the dye biodegradability and each descriptor. Results showed that EHOMO and Mw were the dominant parameters controlling the biodegradability of acid dyes. A statistically robust QSBR model was developed for all studied dyes, with the combined application of EHOMO and Mw. The calculated biodegradations fitted well with the experimental data monitored in a facultative-aerobic process, indicative of the reliable prediction and mechanistic character of the developed model.
基金supported by the National Natural Science Foundation of China (No. 10875019)the Fundamental Research Funds for the Central Universities
文摘The pulsed high-voltage discharge is a new advanced oxidation technology for water treatment. Methyl Orange （MO） dye wastewater was chosen as the target object. Some investigations were conducted on MO decoloration including the discharge characteristics of the multi-needle reactor, parameter optimization, and the degradation mechanism. The following results were obtained. The color group of the azo dye MO was effectively decomposed by water surface plasma. The decoloration rate was promoted with the increase of treatment time, peak voltage, and pulse frequency. When the initial conductivity was 1700 μS/cm, the decoloration rate was the highest. The optimum distance between the needle electrodes and the water surface was 1 mm, the distance between the grounding electrode and the water surface was 28 mm, and the number of needle electrodes and spacing between needles were 24 and 7.5 mm, respectively. The decoloration rate of MO was affected by the gas in the reactor and varied in the order oxygen 〉 air〉 argon 〉 nitrogen, and the energy yield obtained in this investigation was 0.45 g/kWh.
基金Supported by the Foundation of Fujian Education Comm ittee(AJ0 0 15 3)
文摘The Electro-chemistry process to produce Fenton reagents has been described. The in situ oxidation of dyes, acid chrome and alizarin red(Fenton reagents) with electrogenerated hydroxyl radicals was investigated. The \{ I-V \} cyclic voltammograms were measured. The redox peaks of the dyes were not observed in the treated dye solutions instead of a couple of O_2/H_2O_2 redox peaks. The IR results indicate that acid chrome dye was decomposed into naphthylamine and phenol aminophenol sulfonic acid. The degradation and the decolorization of the dyes were comfirmed by the visible spectrum and the chemical analysis. The COD_ cr removing rate was close to 80%.
